Page: 1
SAFETY DATA SHEET
Revision Date: 06/12/2020
Print Date: 8/31/2020
SDS Number: R0027083
Hetron 197 P RESIN
Trademark, INEOS or its subsidiaries, registered
in various countries
30060
Version: 1.10
1 / 21
29 CFR 1910.1200 (OSHA HazCom 2012)
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Product identifier
Trade name : Hetron 197 P
RESIN
Trademark, INEOS or its subsidiaries, registered in
various countries
Relevant identified uses of the substance or mixture and uses advised against
Recommended use
: Industrial chemical
Details of the supplier of the safety data
sheet
INEOS Composites US LLC
5220 Blazer Parkway
Dublin, OH 43017
United States of America (USA)
+1-614-790-9299 (in US)
sds.composites@ineos.com
Emergency telephone number
1-800-424-9300 (+1-703-527-3887 for direct
dial)
Regulatory Information Number
+1-614-790-9299 (in US), or contact your local
customer service representative
Product Information
+1-614-790-9299 (in US)
SECTION 2. HAZARDS IDENTIFICATION
GHS Classification
Flammable liquids
: Category 3
Combustible Dust
:
Skin irritation
: Category 2
Eye irritation
: Category 2A
Specific target organ toxicity
– single exposure
: Category 3 (Respiratory system)
Specific target organ toxicity
– repeated exposure
(Inhalation)
: Category 1 (Auditory system)
GHS label elements
Page: 2
SAFETY DATA SHEET
Revision Date: 06/12/2020
Print Date: 8/31/2020
SDS Number: R0027083
Hetron 197 P RESIN
Trademark, INEOS or its subsidiaries, registered
in various countries
30060
Version: 1.10
2 / 21
Hazard pictograms
:
Signal Word
: Danger
Hazard Statements
: Flammable liquid and vapor.
May form combustible dust concentrations in air.
Causes skin irritation.
Causes serious eye irritation.
May cause respiratory irritation.
Causes damage to organs (Auditory system) through prolonged
or repeated exposure if inhaled.
Precautionary Statements
: Prevention:
Keep away from heat/ sparks/ open flames/ hot surfaces. No
smoking.
Keep container tightly closed.
Ground/bond container and receiving equipment.
Use explosion-proof electrical/ ventilating/ lighting/ equipment.
Use only non-sparking tools.
Take precautionary measures against static discharge.
Do not breathe dust/ fume/ gas/ mist/ vapors/ spray.
Wash skin thoroughly after handling.
Do not eat, drink or smoke when using this product.
Use only outdoors or in a well-ventilated area.
Wear protective gloves/ eye protection/ face protection.
Keep dust/air mixtures away from ignition sources.
Hazardous polymerization can occur under certain conditions.
Avoid excessive heat, direct sunlight, peroxides, and other
polymerization catalysts. Store in a cool place and maintain
proper concentrations of inhibitor and oxygen.
Response:
IF ON SKIN (or hair): Take off immediately all contaminated
clothing. Rinse skin with water/ shower.
IF INHALED: Remove person to fresh air and keep comfortable
for breathing. Call a POISON CENTER/ doctor if you feel
Page: 3
SAFETY DATA SHEET
Revision Date: 06/12/2020
Print Date: 8/31/2020
SDS Number: R0027083
Hetron 197 P RESIN
Trademark, INEOS or its subsidiaries, registered
in various countries
30060
Version: 1.10
3 / 21
unwell.
IF IN EYES: Rinse cautiously with water for several minutes.
Remove contact lenses, if present and easy to do. Continue
rinsing.
Get medical advice/ attention if you feel unwell.
If skin irritation occurs: Get medical advice/ attention.
If eye irritation persists: Get medical advice/ attention.
Take off contaminated clothing and wash before reuse.
In case of fire: Use dry sand, dry chemical or alcohol-resistant
foam to extinguish.
Storage:
Store in a well-ventilated place. Keep container tightly closed.
Store in a well-ventilated place. Keep cool.
Store locked up.
Disposal:
Dispose of contents/ container to an approved waste disposal
plant.
Other hazards
Static Accumulating liquid
Hazardous polymerization may occur.
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Substance / Mixture
: Mixture
Chemical nature
: Static Accumulator
Chemical nature
: Defatter
Hazardous components
Chemical name CAS-No. Classification Concentration (%)
Styrene 100-42-5 Flam. Liq. 3; H226
Acute Tox. 4; H332
Skin Irrit. 2; H315
Eye Irrit. 2A; H319
STOT SE 3; H335
STOT RE 1; H372
Asp. Tox. 1; H304
41.5759
Page: 4
SAFETY DATA SHEET
Revision Date: 06/12/2020
Print Date: 8/31/2020
SDS Number: R0027083
Hetron 197 P RESIN
Trademark, INEOS or its subsidiaries, registered
in various countries
30060
Version: 1.10
4 / 21
SILICA COLLOIDAL
AMORPHOUS
112945-52-5 This material is not
considered hazardous
under the OSHA
Hazard
Communication
Standard (HazCom
2012).
1.00
SECTION 4. FIRST AID MEASURES
General advice
: Move out of dangerous area.
Call a POISON CENTRE or doctor/physician if exposed or
you feel unwell.
Show this safety data sheet to the doctor in attendance.
Do not leave the victim unattended.
If inhaled
: Move to fresh air.
IF INHALED: Call a POISON CENTER/ doctor if you feel
unwell.
Keep patient warm and at rest.
If unconscious, place in recovery position and seek medical
advice.
In case of skin contact
: Remove contaminated clothing. If irritation develops, get
medical attention.
If on skin, rinse well with water.
Wash contaminated clothing before re-use.
If on clothes, remove clothes.
In case of eye contact
: Immediately flush eye(s) with plenty of water.
Remove contact lenses.
Protect unharmed eye.
If swallowed
: Obtain medical attention.
Do not give milk or alcoholic beverages.
Never give anything by mouth to an unconscious person.
If symptoms persist, call a physician.
Most important symptoms
and effects, both acute and
delayed
: Signs and symptoms of exposure to this material through
breathing, swallowing, and/or passage of the material through
the skin may include:
stomach or intestinal upset (nausea, vomiting, diarrhea)
irritation (nose, throat, airways)
Page: 5
SAFETY DATA SHEET
Revision Date: 06/12/2020
Print Date: 8/31/2020
SDS Number: R0027083
Hetron 197 P RESIN
Trademark, INEOS or its subsidiaries, registered
in various countries
30060
Version: 1.10
5 / 21
confusion
Causes skin irritation.
Causes serious eye irritation.
May cause respiratory irritation.
Causes damage to organs through prolonged or repeated
exposure if inhaled.
Notes to physician
: No hazards which require special first aid measures.
SECTION 5. FIREFIGHTING MEASURES
Suitable extinguishing media
: Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Water spray
Foam
Alcohol-resistant foam
Carbon dioxide (CO2)
Dry chemical
Unsuitable extinguishing
media
: High volume water jet
Specific hazards during
firefighting
: Organic dusts at sufficient concentration can form explosive
mixtures in air.
Never use welding or cutting torch on or near drum (even
empty) because product (even just residue) can ignite
explosively.
Beware of vapours accumulating to form explosive
concentrations. Vapours can accumulate in low areas.
Do not allow run-off from fire fighting to enter drains or water
courses.
Hazardous combustion
products
: Hydrocarbons
carbon dioxide and carbon monoxide
Specific extinguishing
methods
:
Product is compatible with standard fire-fighting agents.
Further information : Do not use a solid water stream as it may scatter and spread
fire.
Fire residues and contaminated fire extinguishing water must
Page: 6
SAFETY DATA SHEET
Revision Date: 06/12/2020
Print Date: 8/31/2020
SDS Number: R0027083
Hetron 197 P RESIN
Trademark, INEOS or its subsidiaries, registered
in various countries
30060
Version: 1.10
6 / 21
be disposed of in accordance with local regulations.
Use a water spray to cool fully closed containers.
Polymerization will take place under fire conditions. If
polymerization occurs in a closed container, there is a
possibility it will rupture violently. Cool storage container with
water, if exposed to fire.
Special protective equipment
for firefighters
: In the event of fire, wear self-contained breathing apparatus.
SECTION 6. ACCIDENTAL RELEASE MEASURES
Personal precautions,
protective equipment and
emergency procedures
: Evacuate personnel to safe areas.
Remove all sources of ignition.
Use personal protective equipment.
Ensure adequate ventilation.
Beware of vapours accumulating to form explosive
concentrations. Vapours can accumulate in low areas.
Persons not wearing protective equipment should be excluded
from area of spill until clean-up has been completed.
Environmental precautions
: Prevent product from entering drains.
Prevent further leakage or spillage if safe to do so.
If the product contaminates rivers and lakes or drains inform
respective authorities.
Methods and materials for
containment and cleaning up
: Contain spillage, and then collect with non-combustible
absorbent material, (e.g. sand, earth, diatomaceous earth,
vermiculite) and place in container for disposal according to
local / national regulations (see section 13).
Other information
: Comply with all applicable federal, state, and local regulations.
Suppress (knock down) gases/vapours/mists with a water
spray jet.
SECTION 7. HANDLING AND STORAGE
Advice on safe handling
: Open drum carefully as content may be under pressure.
Avoid formation of aerosol.
Provide sufficient air exchange and/or exhaust in work rooms.
Do not breathe vapours/dust.
Do not smoke.
Page: 7
SAFETY DATA SHEET
Revision Date: 06/12/2020
Print Date: 8/31/2020
SDS Number: R0027083
Hetron 197 P RESIN
Trademark, INEOS or its subsidiaries, registered
in various countries
30060
Version: 1.10
7 / 21
Container hazardous when empty.
Take precautionary measures against static discharges.
Avoid exposure – obtain special instructions before use.
Avoid contact with skin and eyes.
Smoking, eating and drinking should be prohibited in the
application area.
For personal protection see section 8.
Dispose of rinse water in accordance with local and national
regulations.
Secondary operations, such as grinding and sanding, may
produce dust.
Maintain good housekeeping. Do not permit dust layers to
accumulate, for example, on floors, ledges, and equipment, in
order to avoid any potential for dust explosion hazards.
For further guidance on prevention of dust explosions, refer to
National Fire Protection Association (NFPA) 654: Standard
for the Prevention of Fire and Dust Explosions, from the
Manufacturing, Processing and Handling of Combustible
Particulate Solids .
Conditions for safe storage
: Keep container tightly closed in a dry and well-ventilated
place.
Containers which are opened must be carefully resealed and
kept upright to prevent leakage.
Observe label precautions.
No smoking.
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
Components CAS-No. Value type
(Form of
exposure)
Control
parameters /
Permissible
concentration
Basis
Styrene 100-42-5 TWA 50 ppm
215 mg/m3
NIOSH REL
ST 100 ppm
425 mg/m3
NIOSH REL
TWA 100 ppm OSHA Z-2
CEIL 200 ppm OSHA Z-2
Peak 600 ppm OSHA Z-2
TWA 50 ppm
215 mg/m3
OSHA P0
Page: 8
SAFETY DATA SHEET
Revision Date: 06/12/2020
Print Date: 8/31/2020
SDS Number: R0027083
Hetron 197 P RESIN
Trademark, INEOS or its subsidiaries, registered
in various countries
30060
Version: 1.10
8 / 21
STEL 100 ppm
425 mg/m3
OSHA P0
C 500 ppm CAL PEL
PEL 50 ppm
215 mg/m3
CAL PEL
STEL 100 ppm
425 mg/m3
CAL PEL
TWA 20 ppm ACGIH
STEL 40 ppm ACGIH
SILICA COLLOIDAL
AMORPHOUS
112945-52-5 TWA 20 Million
particles per cubic
foot
Dust
(Silica)
OSHA Z-3
TWA 80 mg/m3 /
%SiO2
Dust
(Silica)
OSHA Z-3
TWA 6 mg/m3
(Silica)
NIOSH REL
PEL 6 mg/m3 CAL PEL
Biological occupational exposure limits
Components CAS-No. Control
parameters
Biological
specimen
Sampling
time
Permissible
concentrati
on
Basis
Styrene 100-42-5 Mandelic
acid plus
phenylglyox
ylic acid
Urine End of
shift (As
soon as
possible
after
exposure
ceases)
400 mg/g
Creatinine
ZUS_A
CGIHB
Styrene Urine End of
shift (As
soon as
possible
after
exposure
ceases)
40 g/l ZUS_A
CGIHB
Engineering measures : Provide sufficient mechanical (general and/or local exhaust)
ventilation to maintain exposure below exposure guidelines (if
applicable) or below levels that cause known, suspected or
apparent adverse effects.
Provide appropriate exhaust ventilation at places where dust
is formed.
Page: 9
SAFETY DATA SHEET
Revision Date: 06/12/2020
Print Date: 8/31/2020
SDS Number: R0027083
Hetron 197 P RESIN
Trademark, INEOS or its subsidiaries, registered
in various countries
30060
Version: 1.10
9 / 21
Personal protective equipment
Respiratory protection : In the case of vapour formation use a respirator with an
approved filter.
Filter type : Organic vapour type
Hand protection
Material : Laminate (Barrier or Silvershield )
Break through time : 480 min
Glove thickness : > 0.5 mm
Remarks : The exact break through time can be obtained from the
protective glove producer and this has to be observed. Gloves
should be discarded and replaced if there is any indication of
degradation or chemical breakthrough.
Eye protection : Wear chemical splash goggles when there is the potential for
exposure of the eyes to liquid, vapor or mist.
Skin and body protection : Wear as appropriate:
Impervious clothing
Safety shoes
Flame-resistant clothing
Choose body protection according to the amount and
concentration of the dangerous substance at the work place.
Discard gloves that show tears, pinholes, or signs of wear.
Wear resistant gloves (consult your safety equipment
supplier).
Hygiene measures : Wash hands before breaks and at the end of workday.
When using do not eat or drink.
When using do not smoke.
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Physical state
: liquid
Colour
: amber
Odour
: pungent
Odour Threshold
: No data available
pH
: No data available
Melting point/freezing point : No data available
Page: 10
SAFETY DATA SHEET
Revision Date: 06/12/2020
Print Date: 8/31/2020
SDS Number: R0027083
Hetron 197 P RESIN
Trademark, INEOS or its subsidiaries, registered
in various countries
30060
Version: 1.10
10 / 21
Boiling point/boiling range
: 293 F / 145 C
Flash point
: 29.4 C
Evaporation rate
: > 1
Ethyl Ether = 1
Flammability (solid, gas)
: May form combustible dust concentrations in air (during
processing).
Flammability (liquids) : Static Accumulating liquid
Upper explosion limit
: 7 %(V)
Calculated Explosive Limit
Lower explosion limit
: 1 %(V)
Calculated Explosive Limit
Vapour pressure
: 8.53248 hPa (25 C)
Calculated Vapor Pressure
Relative vapour density
: 3.6(Air = 1.0)
Relative density
: 1.139 (20 C)
Density
: 1.139 g/cm3 (20 C)
Calculated Density/Liquid Density
Solubility(ies)
Water solubility
: insoluble
Solubility in other solvents
: No data available
Partition coefficient: n-
octanol/water
: No data available
Thermal decomposition
: No data available
Viscosity
Viscosity, dynamic
: No data available
Viscosity, kinematic
: > 20.5 mm2/s (40 C)
Oxidizing properties
: No data available
Page: 11
SAFETY DATA SHEET
Revision Date: 06/12/2020
Print Date: 8/31/2020
SDS Number: R0027083
Hetron 197 P RESIN
Trademark, INEOS or its subsidiaries, registered
in various countries
30060
Version: 1.10
11 / 21
SECTION 10. STABILITY AND REACTIVITY
Reactivity
: No decomposition if stored and applied as directed.
Chemical stability
: Stable under recommended storage conditions.
Possibility of hazardous
reactions
: Hazardous polymerisation may occur.
Vapours may form explosive mixture with air.
This product does not present a dust explosion hazard as
delivered. However, fine dust dispersed in air in sufficient
concentrations, and in the presence of an ignition source, is a
potential dust explosion hazard.
Conditions to avoid
: Heat, flames and sparks.
Exposure to air.
Exposure to sunlight.
Incompatible materials
: Acids
aluminum
aluminum chloride
Bases
Copper
Copper alloys
halogens
iron chloride
metal salts
Strong oxidizing agents
Peroxides
Hazardous decomposition
products
carbon dioxide and carbon monoxide
Hydrocarbons
SECTION 11. TOXICOLOGICAL INFORMATION
Information on likely routes of
exposure
: Inhalation
Skin contact
Eye Contact
Ingestion
Acute toxicity
Not classified based on available information.
Components:
Page: 12
SAFETY DATA SHEET
Revision Date: 06/12/2020
Print Date: 8/31/2020
SDS Number: R0027083
Hetron 197 P RESIN
Trademark, INEOS or its subsidiaries, registered
in various countries
30060
Version: 1.10
12 / 21
Styrene:
Acute oral toxicity
: LD50 Oral (Rat): > 2,000 mg/kg
Acute inhalation toxicity
: LC50 (Rat): 11.8 mg/l, 2770 ppm
Exposure time: 4 h
Test atmosphere: vapour
No observed adverse effect level (Humans): 100 ppm
Exposure time: 7 h
Test atmosphere: vapour
Acute dermal toxicity
: LD50 (Rat): > 2,000 mg/kg
Method: OECD Test Guideline 402
Assessment: No adverse effect has been observed in acute
dermal toxicity tests.
SILICA COLLOIDAL AMORPHOUS :
Acute oral toxicity
: LD50 (Rat): > 5,000 mg/kg
Acute dermal toxicity
: LD50 (Rabbit): > 2,000 mg/kg
Assessment: Not classified as acutely toxic by dermal
absorption under GHS.
Skin corrosion/irritation
Causes skin irritation.
Product:
Result: Repeated exposure may cause skin dryness or cracking.
Remarks: May cause skin irritation and/or dermatitis.
Components:
Styrene:
Species: Rabbit
Result: Irritating to skin.
Species: human skin
Result: No skin irritation
SILICA COLLOIDAL AMORPHOUS :
Result: No skin irritation
Serious eye damage/eye irritation
Causes serious eye irritation.
Product:
Remarks: Vapours may cause irritation to the eyes, respiratory system and the skin., Causes
Page: 13
SAFETY DATA SHEET
Revision Date: 06/12/2020
Print Date: 8/31/2020
SDS Number: R0027083
Hetron 197 P RESIN
Trademark, INEOS or its subsidiaries, registered
in various countries
30060
Version: 1.10
13 / 21
serious eye irritation.
Components:
Styrene:
Result: Irritating to eyes.
Remarks: Vapour during processing may be irritating to the respiratory tract and to the eyes.
SILICA COLLOIDAL AMORPHOUS :
Result: No eye irritation
Respiratory or skin sensitisation
Skin sensitisation: Not classified based on available information.
Respiratory sensitisation: Not classified based on available information.
Components:
Styrene:
Exposure routes: Skin contact
Species: Guinea pig
Assessment: Does not cause skin sensitisation.
Result: negative
Exposure routes: inhalation (vapour)
Species: Humans
Assessment: Does not cause respiratory sensitisation.
Result: negative
Germ cell mutagenicity
Not classified based on available information.
Carcinogenicity
Not classified based on available information.
Product:
Carcinogenicity –
Assessment
: Styrene has been tested for carcinogenicity in rats and mice.
Styrene caused lung tumors in mice only. These tumors are
not considered to be relevant to humans.
Reproductive toxicity
Not classified based on available information.
STOT – single exposure
May cause respiratory irritation.
Components:
Styrene:
Assessment: May cause respiratory irritation.
STOT – repeated exposure
Causes damage to organs (Auditory system) through prolonged or repeated exposure if inhaled.
Components:
Styrene:
Exposure routes: inhalation (vapour)
Page: 14
SAFETY DATA SHEET
Revision Date: 06/12/2020
Print Date: 8/31/2020
SDS Number: R0027083
Hetron 197 P RESIN
Trademark, INEOS or its subsidiaries, registered
in various countries
30060
Version: 1.10
14 / 21
Target Organs: Auditory system
Assessment: Causes damage to organs through prolonged or repeated exposure.
Repeated dose toxicity
Components:
Styrene:
Species: Human
85 mg/m3
Application Route: inhalation (vapour)
Species: Human
615 mg/kg
Application Route: Skin contact
Aspiration toxicity
Not classified based on available information.
Components:
Styrene:
May be fatal if swallowed and enters airways.
Further information
Product:
Remarks: Solvents may degrease the skin.
Carcinogenicity:
IARC
Group 2B: Possibly carcinogenic to humans
Styrene
100-42-5
OSHA
No component of this product present at levels greater than or
equal to 0.1% is on OSHA s list of regulated carcinogens.
NTP
Reasonably anticipated to be a human carcinogen
Styrene
100-42-5
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
Product:
Ecotoxicology Assessment
Short-term (acute) aquatic
hazard
: Acute aquatic toxicity Category 2; Toxic to aquatic life.
Long-term (chronic) aquatic : Not classified based on available information.
Page: 15
SAFETY DATA SHEET
Revision Date: 06/12/2020
Print Date: 8/31/2020
SDS Number: R0027083
Hetron 197 P RESIN
Trademark, INEOS or its subsidiaries, registered
in various countries
30060
Version: 1.10
15 / 21
hazard
Components:
Styrene:
Toxicity to fish
: LC50 (Pimephales promelas (fathead minnow)): 4.02 mg/l
Exposure time: 96 h
Toxicity to daphnia and other
aquatic invertebrates
: EC50 (Daphnia magna (Water flea)): 4.7 mg/l
Exposure time: 48 h
Toxicity to algae
: ErC50 (Pseudokirchneriella subcapitata (green algae)): 4.9
mg/l
Exposure time: 72 h
Toxicity to daphnia and other
aquatic invertebrates
(Chronic toxicity)
: NOEC (Daphnia magna (Water flea)): 1.01 mg/l
Exposure time: 21 d
Toxicity to bacteria
: EC50 (activated sludge): ca. 500 mg/l
Exposure time: 0.5 h
Toxicity to soil dwelling
organisms
: NOEC (Eisenia fetida (earthworms)): 34 mg/kg
Exposure time: 14 d
Method: OECD Test Guideline 207
SILICA COLLOIDAL AMORPHOUS :
Toxicity to fish
: LC50 (Brachydanio rerio (zebrafish)): > 10,000 mg/l
Exposure time: 96 h
Method: OECD Test Guideline 203
Persistence and degradability
Components:
Styrene:
Biodegradability
: Result: Readily biodegradable.
Biodegradation: > 60 %
Exposure time: 10 d
SILICA COLLOIDAL AMORPHOUS :
Biodegradability
: Result: The methods for determining biodegradability are not
applicable to inorganic substances.
No data available
Bioaccumulative potential
Components:
Styrene:
Bioaccumulation
: Bioconcentration factor (BCF): < 100 Page: 16 SAFETY DATA SHEET Revision Date: 06/12/2020 Print Date: 8/31/2020 SDS Number: R0027083 Hetron 197 P RESIN Trademark, INEOS or its subsidiaries, registered in various countries 30060 Version: 1.10 16 / 21 Partition coefficient: n- octanol/water : log Pow: 2.96 (25 C) No data available Mobility in soil Components: Styrene: Distribution among environmental compartments : Koc: 352 No data available Other adverse effects Product: Additional ecological information : An environmental hazard cannot be excluded in the event of unprofessional handling or disposal., Toxic to aquatic life. Components: Styrene: Results of PBT and vPvB assessment : This substance is not considered to be persistent, bioaccumulating and toxic (PBT). This substance is not considered to be very persistent and very bioaccumulating (vPvB). SECTION 13. DISPOSAL CONSIDERATIONS Disposal methods General advice : The product should not be allowed to enter drains, water courses or the soil. Do not contaminate ponds, waterways or ditches with chemical or used container. Send to a licensed waste management company. Dispose of in accordance with all applicable local, state and federal regulations. Contaminated packaging : Empty remaining contents. Dispose of as unused product. Empty containers should be taken to an approved waste handling site for recycling or disposal. Do not re-use empty containers. Do not burn, or use a cutting torch on, the empty drum. Page: 17 SAFETY DATA SHEET Revision Date: 06/12/2020 Print Date: 8/31/2020 SDS Number: R0027083 Hetron 197 P RESIN Trademark, INEOS or its subsidiaries, registered in various countries 30060 Version: 1.10 17 / 21 SECTION 14. TRANSPORT INFORMATION International transport regulations REGULATION ID NUMBER PROPER SHIPPING NAME *HAZARD CLASS SUBSIDIARY HAZARDS PACKING GROUP MARINE POLLUTANT / LTD. QTY. MX_DG UN 1866 RESINA, SOLUCIONES DE 3 III INTERNATIONAL AIR TRANSPORT ASSOCIATION - PASSENGER UN 1866 Resin solution 3 III INTERNATIONAL AIR TRANSPORT ASSOCIATION - CARGO UN 1866 Resin solution 3 III INTERNATIONAL MARITIME DANGEROUS GOODS UN 1866 RESIN SOLUTION 3 III TDG_INWT_C UN 1866 RESIN SOLUTION 3 III TDG_RAIL_C UN 1866 RESIN SOLUTION 3 III TDG_ROAD_C UN 1866 RESIN SOLUTION 3 III U.S. DOT - INLAND WATERWAYS UN 1866 Resin solution 3 III CFR_RAIL_C UN 1866 Resin solution 3 III Page: 18 SAFETY DATA SHEET Revision Date: 06/12/2020 Print Date: 8/31/2020 SDS Number: R0027083 Hetron 197 P RESIN Trademark, INEOS or its subsidiaries, registered in various countries 30060 Version: 1.10 18 / 21 U.S. DOT - ROAD UN 1866 Resin solution 3 III *ORM = ORM-D, CBL = COMBUSTIBLE LIQUID Marine pollutant no Dangerous goods descriptions (if indicated above) may not reflect quantity, end-use or region-specific exceptions that can be applied. Consult shipping documents for descriptions that are specific to the shipment. SECTION 15. REGULATORY INFORMATION EPCRA - Emergency Planning and Community Right-to-Know Act CERCLA Reportable Quantity Components CAS-No. Component RQ (lbs) Calculated product RQ (lbs) Styrene 100-42-5 1000 2405 SARA 304 Extremely Hazardous Substances Reportable Quantity This material does not contain any components with a section 304 EHS RQ. SARA 311/312 Hazards : Flammable (gases, aerosols, liquids, or solids) Combustible Dust Hazard not otherwise classified (physical hazards) Skin corrosion or irritation Serious eye damage or eye irritation Specific target organ toxicity (single or repeated exposure) SARA 302 : This material does not contain any components with a section 302 EHS TPQ. SARA 313 The following components are subject to reporting levels established by SARA Title III, Section 313: Styrene 100-42-5 41.57 % California Prop. 65 WARNING: This product can expose you to chemicals including styrene, benzene, formaldehyde, 1,4-dioxane, acetaldehyde, ethylene oxide, which is/are known to the State of California to cause cancer, and benzene, toluene, ethylene oxide, which is/are known to the State of California to cause birth defects or other reproductive harm. For more information go to www.P65Warnings.ca.gov. The components of this product are reported in the following inventories: Page: 19 SAFETY DATA SHEET Revision Date: 06/12/2020 Print Date: 8/31/2020 SDS Number: R0027083 Hetron 197 P RESIN Trademark, INEOS or its subsidiaries, registered in various countries 30060 Version: 1.10 19 / 21 DSL : All components of this product are on the Canadian DSL AICS : On the inventory, or in compliance with the inventory ENCS : On the inventory, or in compliance with the inventory KECI : On the inventory, or in compliance with the inventory PICCS : Not in compliance with the inventory IECSC : On the inventory, or in compliance with the inventory TSCA : On TSCA Inventory Inventories AICS (Australia), DSL (Canada), IECSC (China), REACH (European Union), ENCS (Japan), ISHL (Japan), KECI (Korea), NZIoC (New Zealand), PICCS (Philippines), TCSI (Taiwan), TSCA (USA) - On or in compliance with the active portion of the TSCA inventory SECTION 16. OTHER INFORMATION Further information Revision Date: 06/12/2020 NFPA: HMIS III: NFPA Flammable and Combustible Liquids Classification Flammable Liquid Class IC Full text of H-Statements Flammability Health Instability 2 3 0 FLAMMABILITY PHYSICAL HAZARD HEALTH 3 0 2* Special hazard 0 = not significant, 1 =Slight, 2 = Moderate, 3 = High 4 = Extreme, * = Chronic Page: 20 SAFETY DATA SHEET Revision Date: 06/12/2020 Print Date: 8/31/2020 SDS Number: R0027083 Hetron 197 P RESIN Trademark, INEOS or its subsidiaries, registered in various countries 30060 Version: 1.10 20 / 21 H226 Flammable liquid and vapor. H304 May be fatal if swallowed and enters airways. H315 Causes skin irritation. H319 Causes serious eye irritation. H332 Harmful if inhaled. H335 May cause respiratory irritation. H372 Causes damage to organs through prolonged or repeated exposure if inhaled. Sources of key data used to compile the Safety Data Sheet INEOS internal data including own and sponsored test reports The UNECE administers regional agreements implementing harmonised classification for labelling (GHS) and transport. The information accumulated herein is believed to be accurate but is not warranted to be whether originating with the company or not. Recipients are advised to confirm in advance of need that the information is current, applicable, and suitable to their circumstances. This SDS has been prepared by INEOS's Environmental Health and Safety Department +1-614-790-9299 (in US). Full text of other abbreviations AICS - Australian Inventory of Chemical Substances; ASTM - American Society for the Testing of Materials; bw - Body weight; CERCLA - Comprehensive Environmental Response, Compensation, and Liability Act; CMR - Carcinogen, Mutagen or Reproductive Toxicant; DIN - Standard of the German Institute for Standardisation; DOT - Department of Transportation; DSL - Domestic Substances List (Canada); ECx - Concentration associated with x% response; EHS - Extremely Hazardous Substance; ELx - Loading rate associated with x% response; EmS - Emergency Schedule; ENCS - Existing and New Chemical Substances (Japan); ErCx - Concentration associated with x% growth rate response; ERG - Emergency Response Guide; GHS - Globally Harmonized System; GLP - Good Laboratory Practice; HMIS - Hazardous Materials Identification System; IARC - International Agency for Research on Cancer; IATA - International Air Transport Association; IBC - International Code for the Construction and Equipment of Ships carrying Dangerous Chemicals in Bulk; IC50 - Half maximal inhibitory concentration; ICAO - International Civil Aviation Organization; IECSC - Inventory of Existing Chemical Substances in China; IMDG - International Maritime Dangerous Goods; IMO - International Maritime Organization; ISHL - Industrial Safety and Health Law (Japan); ISO - International Organisation for Standardization; KECI - Korea Existing Chemicals Inventory; LC50 - Lethal Concentration to 50 % of a test population; LD50 - Lethal Dose to 50% of a test population (Median Lethal Dose); MARPOL - International Convention for the Prevention of Pollution from Ships; MSHA - Mine Safety and Health Administration; n.o.s. - Not Otherwise Specified; NFPA - National Fire Protection Association; NO(A)EC - No Observed (Adverse) Effect Concentration; Page: 21 SAFETY DATA SHEET Revision Date: 06/12/2020 Print Date: 8/31/2020 SDS Number: R0027083 Hetron 197 P RESIN Trademark, INEOS or its subsidiaries, registered in various countries 30060 Version: 1.10 21 / 21 NO(A)EL - No Observed (Adverse) Effect Level; NOELR - No Observable Effect Loading Rate; NTP - National Toxicology Program; NZIoC - New Zealand Inventory of Chemicals; OECD - Organization for Economic Co-operation and Development; OPPTS - Office of Chemical Safety and Pollution Prevention; PBT - Persistent, Bioaccumulative and Toxic substance; PICCS - Philippines Inventory of Chemicals and Chemical Substances; (Q)SAR - (Quantitative) Structure Activity Relationship; RCRA - Resource Conservation and Recovery Act; REACH - Regulation (EC) No 1907/2006 of the European Parliament and of the Council concerning the Registration, Evaluation, Authorisation and Restriction of Chemicals; RQ - Reportable Quantity; SADT - Self- Accelerating Decomposition Temperature; SARA - Superfund Amendments and Reauthorization Act; SDS - Safety Data Sheet; TCSI - Taiwan Chemical Substance Inventory; TSCA - Toxic Substances Control Act (United States); UN - United Nations; UNRTDG - United Nations Recommendations on the Transport of Dangerous Goods; vPvB - Very Persistent and Very Bioaccumulative