Safety Data Sheet
according to the OSHA Hazard Communication Standard
SikaBiresin L325 HT (formerly EL-325HTTC) Part A
Revision Date 05/15/2024
Print Date 05/15/2024
1 / 11
SECTION 1. IDENTIFICATION
Product name : SikaBiresin L325 HT (formerly EL-325HTTC) Part A
Company name : Sika Corporation
201 Polito Avenue
Lyndhurst, NJ 07071
USA
www.sikausa.com
Telephone : (201) 933-8800
Telefax : (201) 804-1076
E-mail address : ehs@sika-corp.com
Emergency telephone : CHEMTREC: 800-424-9300
INTERNATIONAL: +1-703-527-3887
Recommended use of the
chemical and restrictions on
use
: For further information, refer to product data sheet.
SECTION 2. HAZARDS IDENTIFICATION
GHS classification in accordance with the OSHA Hazard Communication Standard (29 CFR
1910.1200)
Skin irritation
: Category 2
Eye irritation
: Category 2A
Skin sensitization
: Category 1
GHS label elements
Hazard pictograms
:
Signal Word
: Warning
Hazard Statements
: H315 Causes skin irritation.
H317 May cause an allergic skin reaction.
H319 Causes serious eye irritation.
Precautionary Statements
:
Prevention:
P261 Avoid breathing mist or vapors.
Safety Data Sheet
according to the OSHA Hazard Communication Standard
SikaBiresin L325 HT (formerly EL-325HTTC) Part A
Revision Date 05/15/2024
Print Date 05/15/2024
2 / 11
P264 Wash skin thoroughly after handling.
P272 Contaminated work clothing must not be allowed out of
the workplace.
P280 Wear protective gloves/ eye protection/ face protection.
Response:
P302 + P352 IF ON SKIN: Wash with plenty of soap and water.
P305 + P351 + P338 IF IN EYES: Rinse cautiously with water
for several minutes. Remove contact lenses, if present and easy
to do. Continue rinsing.
P333 + P313 If skin irritation or rash occurs: Get medical advice/
attention.
P337 + P313 If eye irritation persists: Get medical advice/ atten-
tion.
P362 + P364 Take off contaminated clothing and wash it before
reuse.
Disposal:
P501 Dispose of contents/ container to an approved waste dis-
posal plant.
Additional Labeling
There are no ingredients with unknown acute toxicity used in a mixture at a concentration >= 1%.
Other hazards
None known.
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Mixtures
Components
Chemical name CAS-No. Classification Concentra-
tion (% w/w)
bisphenol A-(epichlorhydrin), homo-
polymer
25085-99-8 Skin Irrit. 2; H315
Eye Irrit. 2A; H319
Skin Sens. 1; H317
>= 10 – < 20
bisphenol-F-(epichlorhydrin) epoxy
resin
28064-14-4 Skin Irrit. 2; H315
Eye Irrit. 2A; H319
Skin Sens. 1; H317
>= 5 – < 10
Oxirane, 2,2'-[(1-
methylethylidene)bis(4,1-
phenyleneoxymethylene)]bis-
1675-54-3 Skin Irrit. 2; H315
Eye Irrit. 2A; H319
Skin Sens. 1; H317
>= 5 – < 10
1,3-bis(2,3-epoxypropoxy)-2,2-
dimethylpropane
17557-23-2 Skin Irrit. 2; H315
Skin Sens. 1; H317
>= 1 – < 5
Actual concentration is withheld as a trade secret
SECTION 4. FIRST AID MEASURES
General advice : Move out of dangerous area.
Safety Data Sheet
according to the OSHA Hazard Communication Standard
SikaBiresin L325 HT (formerly EL-325HTTC) Part A
Revision Date 05/15/2024
Print Date 05/15/2024
3 / 11
Consult a physician.
Show this material safety data sheet to the doctor in attend-
ance.
If inhaled : Move to fresh air.
Consult a physician after significant exposure.
In case of skin contact : Take off contaminated clothing and shoes immediately.
Wash off with soap and plenty of water.
If symptoms persist, call a physician.
In case of eye contact : Immediately flush eye(s) with plenty of water.
Remove contact lenses.
Keep eye wide open while rinsing.
If eye irritation persists, consult a specialist.
If swallowed : Clean mouth with water and drink afterwards plenty of water.
Do not induce vomiting without medical advice.
Do not give milk or alcoholic beverages.
Never give anything by mouth to an unconscious person.
Obtain medical attention.
Most important symptoms
and effects, both acute and
delayed
: irritant effects
sensitizing effects
Allergic reactions
Excessive lachrymation
Erythema
Dermatitis
Causes skin irritation.
May cause an allergic skin reaction.
Causes serious eye irritation.
Notes to physician : Treat symptomatically.
SECTION 5. FIRE-FIGHTING MEASURES
Suitable extinguishing media : Use extinguishing measures that are appropriate to local cir-
cumstances and the surrounding environment.
Further information : Collect contaminated fire extinguishing water separately. This
must not be discharged into drains.
Fire residues and contaminated fire extinguishing water must be disposed of in accordance with local regulations.
Special protective equipment
for fire-fighters
: In the event of fire, wear self-contained breathing apparatus.
SECTION 6. ACCIDENTAL RELEASE MEASURES
Personal precautions, protec-: Use personal protective equipment.
Safety Data Sheet
according to the OSHA Hazard Communication Standard
SikaBiresin L325 HT (formerly EL-325HTTC) Part A
Revision Date 05/15/2024
Print Date 05/15/2024
4 / 11
tive equipment and emer-
gency procedures
Deny access to unprotected persons.
Environmental precautions
: Do not flush into surface water or sanitary sewer system.
Local authorities should be advised if significant spillages
cannot be contained.
Methods and materials for
containment and cleaning up
: Soak up with inert absorbent material (e.g. sand, silica gel,
acid binder, universal binder, sawdust).
Keep in suitable, closed containers for disposal.
SECTION 7. HANDLING AND STORAGE
Advice on protection against
fire and explosion
: Normal measures for preventive fire protection.
Advice on safe handling : Avoid exceeding the given occupational exposure limits (see
section 8).
Do not get in eyes, on skin, or on clothing.
For personal protection see section 8.
Persons with a history of skin sensitization problems or asth-
ma, allergies, chronic or recurrent respiratory disease should
not be employed in any process in which this mixture is being
used.
Smoking, eating and drinking should be prohibited in the ap-
plication area.
Follow standard hygiene measures when handling chemical
products.
Conditions for safe storage : Keep container tightly closed in a dry and well-ventilated
place.
Store in accordance with local regulations.
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Ingredients with workplace control parameters
Contains no substances with occupational exposure limit values.
Engineering measures : Use of adequate ventilation should be sufficient to control
worker exposure to airborne contaminants. If the use of this
product generates dust, fumes, gas, vapor or mist, use pro-
cess enclosures, local exhaust ventilation or other engineer-
ing controls to keep worker exposure below any recommend-
ed or statutory limits.
Personal protective equipment
Respiratory protection : Use a properly fitted NIOSH approved air-purifying or air-fed
respirator complying with an approved standard if a risk as- sessment indicates this is necessary.
Safety Data Sheet
according to the OSHA Hazard Communication Standard
SikaBiresin L325 HT (formerly EL-325HTTC) Part A
Revision Date 05/15/2024
Print Date 05/15/2024
5 / 11
The filter class for the respirator must be suitable for the max-
imum expected contaminant concentration
(gas/vapor/aerosol/particulates) that may arise when han-
dling the product. If this concentration is exceeded, self-
contained breathing apparatus must be used.
Hand protection : Chemical-resistant, impervious gloves complying with an
approved standard should be worn at all times when handling
chemical products if a risk assessment indicates this is nec-
essary.
Eye protection : Safety eyewear complying with an approved standard should
be used when a risk assessment indicates this is necessary.
Skin and body protection : Choose body protection in relation to its type, to the concen-
tration and amount of dangerous substances, and to the spe-
cific work-place.
Hygiene measures : Avoid contact with skin, eyes and clothing.
Wash hands before breaks and immediately after handling the product.
Remove contaminated clothing and protective equipment before entering eating areas.
Wash thoroughly after handling.
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance : paste
Color : light brown
Odor : mild
Odor Threshold : No data available
pH : Not applicable
Melting point/range / Freezing
point
: No data available
Boiling point/boiling range
: > 392 F / > 200 C
Flash point : > 201 F / > 94 C
(Method: closed cup)
Evaporation rate : No data available
Flammability (solid, gas)
: No data available
Upper explosion limit / Upper
flammability limit
: No data available
Safety Data Sheet
according to the OSHA Hazard Communication Standard
SikaBiresin L325 HT (formerly EL-325HTTC) Part A
Revision Date 05/15/2024
Print Date 05/15/2024
6 / 11
Lower explosion limit / Lower
flammability limit
: No data available
Vapor pressure : 0.01 hpa
Relative vapor density : No data available
Density : 1.06 g/cm3 (68 F / 20 C)
Solubility(ies)
Water solubility : No data available
Solubility in other solvents : No data available
Partition coefficient: n-
octanol/water
: No data available
Autoignition temperature : No data available
Decomposition temperature : No data available
Viscosity
Viscosity, dynamic : No data available
Viscosity, kinematic : > 20.5 mm2/s (104 F / 40 C)
Explosive properties : No data available
Oxidizing properties : No data available
Volatile organic compounds
(VOC) content
: Not applicable
SECTION 10. STABILITY AND REACTIVITY
Reactivity : No dangerous reaction known under conditions of normal use.
Chemical stability : The product is chemically stable.
Possibility of hazardous reac-
tions
: Stable under recommended storage conditions.
Conditions to avoid : No data available
Incompatible materials : No data available
Hazardous decomposition
products
: No decomposition if stored and applied as directed.
Safety Data Sheet
according to the OSHA Hazard Communication Standard
SikaBiresin L325 HT (formerly EL-325HTTC) Part A
Revision Date 05/15/2024
Print Date 05/15/2024
7 / 11
SECTION 11. TOXICOLOGICAL INFORMATION
Acute toxicity
Not classified due to lack of data.
Components:
bisphenol-F-(epichlorhydrin) epoxy resin:
Acute oral toxicity : LD50 Oral (Rat): > 5,000 mg/kg
Oxirane, 2,2′-[(1-methylethylidene)bis(4,1-phenyleneoxymethylene)]bis-:
Acute oral toxicity : LD50 Oral (Rat): > 5,000 mg/kg
Acute dermal toxicity : LD50 Dermal (Rabbit): > 5,000 mg/kg
Skin corrosion/irritation
Causes skin irritation.
Serious eye damage/eye irritation
Causes serious eye irritation.
Respiratory or skin sensitization
Skin sensitization
May cause an allergic skin reaction.
Respiratory sensitization
Not classified due to lack of data.
Germ cell mutagenicity
Not classified due to lack of data.
Carcinogenicity
Not classified due to lack of data.
IARC Not applicable
OSHA Not applicable
NTP Not applicable
Reproductive toxicity
Not classified due to lack of data.
STOT-single exposure
Not classified due to lack of data.
STOT-repeated exposure
Not classified due to lack of data.
Once sensitized, a severe allergic reaction may occur when subsequently exposed to very low levels.
Safety Data Sheet
according to the OSHA Hazard Communication Standard
SikaBiresin L325 HT (formerly EL-325HTTC) Part A
Revision Date 05/15/2024
Print Date 05/15/2024
8 / 11
Aspiration toxicity
Not classified due to lack of data.
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
Components:
Oxirane, 2,2′-[(1-methylethylidene)bis(4,1-phenyleneoxymethylene)]bis-:
Toxicity to fish : LC50 (Oncorhynchus mykiss (rainbow trout)): 2 mg/l
Exposure time: 96 h
Toxicity to daphnia and other
aquatic invertebrates
: EC50 (Daphnia magna (Water flea)): 1.8 mg/l
Exposure time: 48 h
Persistence and degradability
No data available
Bioaccumulative potential
No data available
Mobility in soil
No data available
Other adverse effects
Product:
Additional ecological infor-
mation
: Do not empty into drains; dispose of this material and its con-
tainer in a safe way.
Avoid dispersal of spilled material and runoff and contact with
soil, waterways, drains and sewers.
Toxic to aquatic organisms, may cause long- term adverse
effects in the aquatic environment.
May be harmful to the environment if released in large quanti-
ties.
Water polluting material.
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
Waste from residues : Disposal of this product, solutions and any by-products should
at all times comply with the requirements of environmental protection and waste disposal legislation and any regional
local authority requirements.
Contaminated packaging : Empty containers should be taken to an approved waste han-
dling site for recycling or disposal.
Safety Data Sheet
according to the OSHA Hazard Communication Standard
SikaBiresin L325 HT (formerly EL-325HTTC) Part A
Revision Date 05/15/2024
Print Date 05/15/2024
9 / 11
SECTION 14. TRANSPORT INFORMATION
International Regulations
IATA-DGR
UN/ID No. : UN 3082
Proper shipping name : Environmentally hazardous substance, liquid, n.o.s.
(reaction product: bisphenol A-(epichlorhydrin), homopoly-
mer, epoxy resin)
Class : 9
Packing group : III
Labels : Miscellaneous
Packing instruction (cargo
aircraft)
: 964
Packing instruction (passen-
ger aircraft)
: 964
IMDG-Code
UN number : UN 3082
Proper shipping name : ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID,
N.O.S.
(reaction product: bisphenol A-(epichlorhydrin),
homopolymer, epoxy resin)
Class : 9
Packing group : III
Labels : 9
EmS Code : F-A, S-F
Marine pollutant : yes
Domestic regulation
49 CFR
Not regulated as a dangerous good
DOT: As per 49 CFR 171.4, Non- bulk materials (<119 Gal) are exempt from being classified as a Marine Pollutant. IMDG: For Limited Quantity special provisions reference IMDG Code Chapter 3.4 Special precautions for user The transport classification(s) provided herein are for informational purposes only, and solely based upon the properties of the unpackaged material as it is described within this Safety Data Sheet. Transportation classifications may vary by mode of transportation, package sizes, and variations in regional or country regulations. SECTION 15. REGULATORY INFORMATION TSCA list : All chemical substances in this product are either listed as ac- tive on the TSCA Inventory or are in compliance with a TSCA Inventory exemption. The following substance(s) is/are subject to a Significant New Use Rule: Epoxy Modified Resin- ACCN# 126002 Not Assigned See 40 CFR 721.7210 Safety Data Sheet according to the OSHA Hazard Communication Standard SikaBiresin L325 HT (formerly EL-325HTTC) Part A Revision Date 05/15/2024 Print Date 05/15/2024 10 / 11 The following substance(s) is/are subject to TSCA 12(b) export notification requirements: Epoxy Modified Resin- ACCN# 126002 Not Assigned CERCLA Reportable Quantity Listed substances in the product are at low enough levels to not be expected to exceed the RQ SARA 304 Extremely Hazardous Substances Reportable Quantity Listed substances in the product are at low enough levels to not be expected to exceed the RQ SARA 302 Extremely Hazardous Substances Threshold Planning Quantity This material does not contain any components with a section 302 EHS TPQ. SARA 311/312 Hazards : Respiratory or skin sensitization Skin corrosion or irritation Serious eye damage or eye irritation SARA 313 : This material does not contain any chemical components with known CAS numbers that exceed the threshold (De Minimis) reporting levels established by SARA Title III, Section 313. Clean Air Act This product does not contain any hazardous air pollutants (HAP), as defined by the U.S. Clean Air Act Section 112 (40 CFR 61). California Prop. 65 WARNING: This product can expose you to chemicals including glass, oxide, chemicals, which is known to the State of California to cause cancer, and methanol, which is known to the State of Cali- fornia to cause birth defects or other reproductive harm. For more information go to www.P65Warnings.ca.gov. SECTION 16. OTHER INFORMATION Full text of other abbreviations Notes to Reader The information contained in this Safety Data Sheet applies only to the actual Sika Corporation ("Sika") product identified and described herein. This information is not intended to address, nor does it address the use or application of the identified Sika product in combination with any other material, product or process. All of the information set forth herein is based on technical data re- garding the identified product that Sika believes to be reliable as of the date hereof. Prior to each use of any Sika product, the user must always read and follow the warnings and instructions on the product's current Product Data Sheet, product label and Safety Data Sheet for each Sika product, which are available at web site and/or telephone number listed in Section 1 of this SDS. Safety Data Sheet according to the OSHA Hazard Communication Standard SikaBiresin L325 HT (formerly EL-325HTTC) Part A Revision Date 05/15/2024 Print Date 05/15/2024 11 / 11 SIKA MAKES NO WARRANTIES EXPRESS OR IMPLIED AND ASSUMES NO LIABILITY ARISING FROM THIS INFORMATION OR ITS USE. SIKA SHALL NOT BE LIABLE UNDER ANY LEGAL THEORY FOR SPECIAL OR CONSEQUENTIAL DAMAGES AND SHALL NOT BE RESPONSIBLE FOR THE USE OF THIS PRODUCT IN A MANNER TO INFRINGE ON ANY PATENT OR ANY OTHER INTELLECTUAL PROPERTY RIGHTS HELD BY OTHERS. All sales of Sika products are subject to its current terms and conditions of sale available at www.sikausa.com or 201- 933-8800. Revision Date 05/15/2024 100000035327 US / Z8