by | Sep 27, 2025
SAFETY DATA SHEET
1. Identification
TR-110 Seal Wax /TR-111 Slurry Wax (TR-111CS & WRW)Product identifier
Other means of identification
MR110, MR111, MR111-CS & MR-WRWProduct code
Release agent.Recommended use
None known.Recommended restrictions
Manufacturer/Importer/Supplier/Distributor information
TR Industries a Division of Granitize Products Inc.Company name
11022 Vulcan StreetAddress
South Gate, CA 90280-0893
United States
(562) 923-5438Telephone
CHEMTREC: (800) 424-9300Emergency telephone
CHEMTREC International: 00 1-703-527-3887
2. Hazard(s) identification
Category 2Flammable solidsPhysical hazards
Category 3 narcotic effectsSpecific target organ toxicity, single exposureHealth hazards
Not classified.OSHA defined hazards
Label elements
Signal word Warning
Hazard statement Flammable solid. May cause drowsiness or dizziness.
Precautionary statement
Prevention Keep away from heat/sparks/open flames/hot surfaces. – No smoking. Ground/bond container and
receiving equipment. Use explosion-proof electrical/ventilating/lighting// equipment. Avoid
breathing vapors. Use only outdoors or in a well-ventilated area. Wear protective gloves/protective
clothing/eye protection/face protection.
Response If inhaled: Remove person to fresh air and keep comfortable for breathing. In case of fire: Use
water fog, alcohol resistant foam, dry chemical powder, carbon dioxide (CO2) to extinguish. Call a
poison center/doctor if you feel unwell.
Storage Store in a well-ventilated place. Keep container tightly closed. Store locked up.
Disposal Dispose of contents/container in accordance with local/regional/national/international regulations.
Hazard(s) not otherwise
classified (HNOC)
None known.
Supplemental information None.
3. Composition/information on ingredients
Mixtures
CAS numbe
r %Chemical name
64742-48-9Naphtha (petroleum), hydrotreated
heavy
70 – 90
All concentrations are in percent by weight unless ingredient is a gas. Gas concentrations are in
percent by volume. Components not listed are either non-hazardous or are below reportable limits.
Composition comments
TR-110 Seal Wax /TR-111 Slurry Wax (TR-111CS & WRW) SDS US
959665 Version #: 02 Revision date: 20-September-2021 Issue date: 20-September-2021
1 / 7
4. First-aid measures
Remove victim to fresh air and keep at rest in a position comfortable for breathing. If breathing is
difficult, give oxygen. Call a poison center or doctor/physician if you feel unwell.
Inhalation
Immediately flush with plenty of water for at least 15 minutes while removing contaminated clothing
and shoes. Destroy or thoroughly clean contaminated shoes.
Skin contact
Do not rub eyes. Immediately flush eyes with plenty of water for at least 15 minutes. Continue
rinsing. Get medical attention if irritation develops and persists.
Eye contact
If vomiting occurs, keep head low so that stomach content does not get into the lungs. Get medical
attention immediately. Never give anything by mouth to a victim who is unconscious or is having
convulsions.
Ingestion
May cause drowsiness and dizziness. Narcosis. Headache. Nausea, vomiting. May cause redness
and pain.
Most important
symptoms/effects, acute and
delayed
Provide general supportive measures and treat symptomatically. Thermal burns: Flush with water
immediately. While flushing, remove clothes which do not adhere to affected area. Call an
ambulance. Continue flushing during transport to hospital. Keep victim warm. Keep victim under
observation. Symptoms may be delayed.
Indication of immediate
medical attention and special
treatment needed
Take off contaminated clothing and shoes immediately. Ensure that medical personnel are aware
of the material(s) involved, and take precautions to protect themselves. Show this safety data
sheet to the doctor in attendance. Wash contaminated clothing before re-use.
General information
5. Fire-fighting measures
Water fog. Alcohol resistant foam. Carbon dioxide (CO2). Dry chemical powder, carbon dioxide,
sand or earth may be used for small fires only.
Suitable extinguishing media
Do not use water jet as an extinguisher, as this will spread the fire.Unsuitable extinguishing
media
During fire, gases hazardous to health may be formed.Specific hazards arising from
the chemical
Self-contained breathing apparatus and full protective clothing must be worn in case of fire.Special protective equipment
and precautions for firefighters
In case of fire and/or explosion do not breathe fumes. Move containers from fire area if you can do
so without risk.
Fire fighting
equipment/instructions
Use standard firefighting procedures and consider the hazards of other involved materials.Specific methods
Flammable solid.General fire hazards
6. Accidental release measures
Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Remove all
possible sources of ignition in the surrounding area. Wear appropriate protective equipment and
clothing during clean-up. Ensure adequate ventilation. Use appropriate containment to avoid
environmental contamination. Transfer by mechanical means such as vacuum truck to a salvage
tank or other suitable container for recovery or safe disposal. Local authorities should be advised if
significant spillages cannot be contained. For personal protection, see section 8 of the SDS.
Personal precautions,
protective equipment and
emergency procedures
Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Take
precautionary measures against static discharge. Use only non-sparking tools. This product is
miscible in water. Stop the flow of material, if this is without risk.
Large Spills: Wet down with water and dike for later disposal. Shovel the material into waste
container. Following product recovery, flush area with water.
Small Spills: Sweep up or vacuum up spillage and collect in suitable container for disposal.
Never return spills to original containers for re-use. For waste disposal, see section 13 of the SDS.
Methods and materials for
containment and cleaning up
Avoid discharge into drains, water courses or onto the ground. Use appropriate containment to
avoid environmental contamination.
Environmental precautions
TR-110 Seal Wax /TR-111 Slurry Wax (TR-111CS & WRW) SDS US
959665 Version #: 02 Revision date: 20-September-2021 Issue date: 20-September-2021
2 / 7
7. Handling and storage
Provide adequate precautions, such as electrical grounding and bonding, or inert atmospheres. Do
not handle, store or open near an open flame, sources of heat or sources of ignition. Protect
material from direct sunlight. When using do not smoke. Explosion-proof general and local exhaust
ventilation. Minimize fire risks from flammable and combustible materials (including combustible
dust and static accumulating liquids) or dangerous reactions with incompatible materials. Handling
operations that can promote accumulation of static charges include but are not limited to: mixing,
filtering, pumping at high flow rates, splash filling, creating mists or sprays, tank and container
filling, tank cleaning, sampling, gauging, switch loading, vacuum truck operations. Wear
appropriate personal protective equipment. Observe good industrial hygiene practices.
Precautions for safe handling
Store locked up. Keep away from heat, sparks and open flame. Eliminate sources of ignition. Avoid
spark promoters. Ground/bond container and equipment. These alone may be insufficient to
remove static electricity. Store in a cool, dry place out of direct sunlight. Store in tightly closed
container. Store in a well-ventilated place. Keep in an area equipped with sprinklers. Store away
from incompatible materials (see Section 10 of the SDS).
Conditions for safe storage,
including any incompatibilities
8. Exposure controls/personal protection
No exposure limits noted for ingredient(s).Occupational exposure limits
No biological exposure limits noted for the ingredient(s).Biological limit values
Occupational Exposure Limits are not relevant to the current physical form of the product.Exposure guidelines
Explosion-proof general and local exhaust ventilation. Good general ventilation should be used.
Ventilation rates should be matched to conditions. If applicable, use process enclosures, local
exhaust ventilation, or other engineering controls to maintain airborne levels below recommended
exposure limits. If exposure limits have not been established, maintain airborne levels to an
acceptable level.
Appropriate engineering
controls
Individual protection measures, such as personal protective equipment
Wear safety glasses with side shields (or goggles).Eye/face protection
Skin protection
Wear appropriate chemical resistant gloves. Rubber gloves, butyl rubber, neoprene or PVC gloves
are recommended. Other suitable gloves can be recommended by the glove supplier.
Hand protection
Skin protection
Wear appropriate chemical resistant clothing. Use of an impervious apron is recommended.Other
If engineering controls do not maintain airborne concentrations below recommended exposure
limits (where applicable) or to an acceptable level (in countries where exposure limits have not
been established), an approved respirator must be worn. Check with respiratory protective
equipment suppliers.
Respiratory protection
Wear appropriate thermal protective clothing, when necessary.Thermal hazards
When using do not smoke. Always observe good personal hygiene measures, such as washing
after handling the material and before eating, drinking, and/or smoking. Routinely wash work
clothing and protective equipment to remove contaminants.
General hygiene
considerations
9. Physical and chemical properties
Appearance
Solid.Physical state
Solid.Form
Various.Color
Characteristic.Odor
Odor threshold Not available.
pH Not available.
Melting point/freezing pointNot available.
Initial boiling point and boiling
range
309.92 – 404.6 F (154.4 – 207 C)
Flash point 120.02 F (48.9 C)
Evaporation rate 0.1 (Butyl acetate = 1)
Flammable solid.Flammability (solid, gas)
Upper/lower flammability or explosive limits
Explosive limit – lower (%)Not available.
TR-110 Seal Wax /TR-111 Slurry Wax (TR-111CS & WRW) SDS US
959665 Version #: 02 Revision date: 20-September-2021 Issue date: 20-September-2021
3 / 7
Explosive limit – upper (%)Not available.
Vapor pressure Not available.
Vapor density 1.79 (Air = 1)
Relative density 0.81 (Water = 1)
Solubility(ies)
Solubility (water) Negligible in water.
Partition coefficient
(n-octanol/water)
Not available.
Auto-ignition temperature Not available.
Decomposition temperature Not available.
Viscosity Not available.
Other information
Not explosive.Explosive properties
Not oxidizing.Oxidizing properties
Percent volatile 82 %
10. Stability and reactivity
The product is stable and non-reactive under normal conditions of use, storage and transport.Reactivity
Material is stable under normal conditions.Chemical stability
No dangerous reaction known under conditions of normal use.Possibility of hazardous
reactions
Heat, flames and sparks. Avoid temperatures exceeding the flash point. Contact with incompatible
materials.
Conditions to avoid
Strong oxidizing agents.Incompatible materials
No hazardous decomposition products are known.Hazardous decomposition
products
11. Toxicological information
Information on likely routes of exposure
Inhalation May cause drowsiness and dizziness.
Skin contact Repeated exposure may cause skin dryness or cracking.
Eye contac
t Direct contact with eyes may cause temporary irritation.
Ingestion Ingestion may cause irritation and malaise.
Symptoms related to the
physical, chemical and
toxicological characteristics
May cause drowsiness and dizziness. Narcosis. Headache. Nausea, vomiting. May cause
redness and pain.
Information on toxicological effects
Acute toxicit
y Not expected to be acutely toxic.
Repeated exposure may cause skin dryness or cracking.Skin corrosion/irritation
May cause eye irritation on direct contact.Serious eye damage/eye
irritation
Respiratory or skin sensitization
Respiratory sensitizationNot a respiratory sensitizer.
Not a skin sensitizer.Skin sensitization
No data available to indicate product or any components present at greater than 0.1% are
mutagenic or genotoxic.
Germ cell mutagenicity
Carcinogenicity Not classifiable as to carcinogenicity to humans.
IARC Monographs. Overall Evaluation of Carcinogenicity
Naphtha (petroleum), hydrotreated heavy
(CAS 64742-48-9)
3 Not classifiable as to carcinogenicity to humans.
NTP Report on Carcinogens
Not listed.
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1053)
Not listed.
TR-110 Seal Wax /TR-111 Slurry Wax (TR-111CS & WRW) SDS US
959665 Version #: 02 Revision date: 20-September-2021 Issue date: 20-September-2021
4 / 7
This product is not expected to cause reproductive or developmental effects.Reproductive toxicity
Specific target organ toxicity –
single exposure
May cause drowsiness and dizziness.
Specific target organ toxicity –
repeated exposure
Not classified.
Aspiration hazard Not relevant, due to the form of the product.
Chronic effects Prolonged inhalation may be harmful.
Further information None known.
12. Ecological information
The product is not classified as environmentally hazardous. However, this does not exclude the
possibility that large or frequent spills can have a harmful or damaging effect on the environment.
Ecotoxicity
No data is available on the degradability of any ingredients in the mixture. Persistence and degradability
No data available.Bioaccumulative potential
The product is insoluble or slightly soluble in water. Expected to have low mobility in soil.Mobility in soil
Other adverse effects The product contains volatile organic compounds which have a photochemical ozone creation
potential.
13. Disposal considerations
Collect and reclaim or dispose in sealed containers at licensed waste disposal site. Incinerate the
material under controlled conditions in an approved incinerator. Do not incinerate sealed
containers. If discarded, this product is considered a RCRA ignitable waste, D001. Dispose of
contents/container in accordance with local/regional/national/international regulations.
Disposal instructions
Dispose in accordance with all applicable regulations.Local disposal regulations
D001: Waste Flammable material with a flash point <140 F
The waste code should be assigned in discussion between the user, the producer and the waste
disposal company.
Hazardous waste code
Dispose of in accordance with local regulations. Empty containers or liners may retain some
product residues. This material and its container must be disposed of in a safe manner (see:
Disposal instructions).
Waste from residues / unused
products
Since emptied containers may retain product residue, follow label warnings even after container is
emptied. Empty containers should be taken to an approved waste handling site for recycling or
disposal.
Contaminated packaging
14. Transport information
DOT
UN1325UN number
Flammable solids, organic, n.o.s. (Naphtha (petroleum), hydrotreated heavy)UN proper shipping name
4.1Class
Transport hazard class(es)
-Subsidiary risk
4.1Label(s)
IIIPacking group
NoMarine pollutant
Environmental hazards
Read safety instructions, SDS and emergency procedures before handling.Special precautions for user
A1, IB8, IP3, T1, TP33Special provisions
151Packaging exceptions
213Packaging non bulk
240Packaging bulk
IATA
UN1325UN number
Flammable solid, organic, n.o.s. (Naphtha (petroleum), hydrotreated heavy)UN proper shipping name
4.1Class
Transport hazard class(es)
-Subsidiary risk
4.1Label(s)
IIIPacking group
NoEnvironmental hazards
TR-110 Seal Wax /TR-111 Slurry Wax (TR-111CS & WRW) SDS US
959665 Version #: 02 Revision date: 20-September-2021 Issue date: 20-September-2021
5 / 7
3LERG Code
Read safety instructions, SDS and emergency procedures before handling.Special precautions for user
IMDG
UN1325UN number
FLAMMABLE SOLID, ORGANIC, N.O.S. (NAPHTHA (PETROLEUM), HYDROTREATED HEAVY)UN proper shipping name
4.1Class
Transport hazard class(es)
-Subsidiary risk
IIIPacking group
NoMarine pollutant
Environmental hazards
F-A, S-GEmS
Read safety instructions, SDS and emergency procedures before handling.Special precautions for user
Not applicable.Transport in bulk according to
Annex II of MARPOL 73/78 and
the IBC Code
15. Regulatory information
This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication
Standard, 29 CFR 1910.1200.
US federal regulations
TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D)
Not regulated.
CERCLA Hazardous Substance List (40 CFR 302.4)
Not listed.
SARA 304 Emergency release notification
Not regulated.
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1053)
Not listed.
Toxic Substances Control Act (TSCA) All components of the mixture on the TSCA 8(b) inventory are designated
active .
SARA 302 Extremely hazardous substance
Superfund Amendments and Reauthorization Act of 1986 (SARA)
Not listed.
YesSARA 311/312 Hazardous
chemical
Flammable (gases, aerosols, liquids, or solids)
Specific target organ toxicity (single or repeated exposure)
Classified hazard
categories
SARA 313 (TRI reporting)
Not regulated.
Other federal regulations
Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List
Not regulated.
Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130)
Not regulated.
Not regulated.Safe Drinking Water Act
(SDWA)
US state regulations
US. Massachusetts RTK - Substance List
Not regulated.
US. New Jersey Worker and Community Right-to-Know Act
Not listed.
US. Pennsylvania Worker and Community Right-to-Know Law
Naphtha (petroleum), hydrotreated heavy (CAS 64742-48-9)
US. Rhode Island RTK
Not regulated.
TR-110 Seal Wax /TR-111 Slurry Wax (TR-111CS & WRW) SDS US
959665 Version #: 02 Revision date: 20-September-2021 Issue date: 20-September-2021
6 / 7
California Proposition 65
California Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65): This material
is not known to contain any chemicals currently listed as carcinogens or reproductive toxins. For
more information go to www.P65Warnings.ca.gov.
US. California. Candidate Chemicals List. Safer Consumer Products Regulations (Cal. Code Regs, tit. 22, 69502.3,
subd. (a))
Naphtha (petroleum), hydrotreated heavy (CAS 64742-48-9)
International Inventories
Country(s) or region Inventory name On inventory (yes/no)*
YesAustralia Australian Inventory of Industrial Chemicals (AICIS)
YesCanada Domestic Substances List (DSL)
NoCanada Non-Domestic Substances List (NDSL)
YesChina Inventory of Existing Chemical Substances in China (IECSC)
YesEurope European Inventory of Existing Commercial Chemical
Substances (EINECS)
NoEurope European List of Notified Chemical Substances (ELINCS)
NoJapan Inventory of Existing and New Chemical Substances (ENCS)
YesKorea Existing Chemicals List (ECL)
YesNew Zealand New Zealand Inventory
YesPhilippines Philippine Inventory of Chemicals and Chemical Substances
(PICCS)
YesTaiwan Taiwan Chemical Substance Inventory (TCSI)
YesUnited States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory
*A "Yes" indicates that all components of this product comply with the inventory requirements administered by the governing country(s)
A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing
country(s).
16. Other information, including date of preparation or last revision
20-September-2021Issue date
20-September-2021Revision date
Version # 02
NFPA ratings
02
2
TR Industries cannot anticipate all conditions under which this information and its product, or the
products of other manufacturers in combination with its product, may be used. It is the user s
responsibility to ensure safe conditions for handling, storage and disposal of the product, and to
assume liability for loss, injury, damage or expense due to improper use. The information in the
sheet was written based on the best knowledge and experience currently available.
Disclaimer
TR-110 Seal Wax /TR-111 Slurry Wax (TR-111CS & WRW) SDS US
959665 Version #: 02 Revision date: 20-September-2021 Issue date: 20-September-2021
7 / 7
by | Sep 27, 2025
SAFETY DATA SHEET
1. Identification
White Release Wax Low ViscocityProduct identifier
Other means of identification
MRWRWBLVProduct code
Liquid wax.Recommended use
None known.Recommended restrictions
Manufacturer/Importer/Supplier/Distributor information
Granitize Products, Inc.Manufacturer/Supplier
11022 Vulcan Street
South Gate, CA 90280-0893 US
(562) 923-5438Telephone:
CHEMTREC: (800) 424-9300Emergency
CHEMTREC International: 00 1-703-527-3887
2. Hazard(s) identification
Category 2Flammable liquidsPhysical hazards
Category 2Skin corrosion/irritationHealth hazards
Category 2ASerious eye damage/eye irritation
Category 2Reproductive toxicity
Category 3 narcotic effectsSpecific target organ toxicity, single exposure
Category 2 (central nervous system, lung)Specific target organ toxicity, repeated
exposure
Category 1Aspiration hazard
Category 2Hazardous to the aquatic environment, acute
hazard
Environmental hazards
Category 2Hazardous to the aquatic environment,
long-term hazard
Not classified.OSHA defined hazards
Label elements
Signal word Danger
Hazard statement Highly flammable liquid and vapor. May be fatal if swallowed and enters airways. Causes skin
irritation. Causes serious eye irritation. May cause drowsiness or dizziness. Suspected of
damaging fertility or the unborn child. May cause damage to organs (central nervous system,
lung) through prolonged or repeated exposure. Toxic to aquatic life with long lasting effects.
Precautionary statement
Prevention Obtain special instructions before use. Do not handle until all safety precautions have been read
and understood. Keep away from heat/sparks/open flames/hot surfaces. – No smoking. Keep
container tightly closed. Ground/bond container and receiving equipment. Use explosion-proof
electrical/ventilating/lighting equipment. Use only non-sparking tools. Take precautionary
measures against static discharge. Do not breathe mist or vapor. Wash thoroughly after handling.
Use only outdoors or in a well-ventilated area. Avoid release to the environment. Wear protective
gloves/protective clothing/eye protection/face protection.
White Release Wax Low Viscocity SDS US
944605 Version #: 01 Revision date: – Issue date: 27-June-2018 1 / 11
Response If swallowed: Immediately call a poison center/doctor. Do NOT induce vomiting. If on skin (or hair):
Take off immediately all contaminated clothing. Rinse skin with water/shower. If inhaled: Remove
person to fresh air and keep comfortable for breathing. If in eyes: Rinse cautiously with water for
several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If exposed
or concerned: Get medical advice/attention. Call a poison center/doctor if you feel unwell. If skin
irritation occurs: Get medical advice/attention. If eye irritation persists: Get medical
advice/attention. Take off contaminated clothing and wash before reuse. In case of fire: Use
appropriate media to extinguish. In case of fire: Use water fog, alcohol resistant foam, dry
chemical powder, carbon dioxide (CO2) to extinguish. Collect spillage.
Storage Keep cool. Store in a well-ventilated place. Keep container tightly closed. Store locked up.
Disposal Dispose of contents/container in accordance with local/regional/national/international regulations.
Hazard(s) not otherwise
classified (HNOC)
None known.
Supplemental information None.
3. Composition/information on ingredients
Mixtures
64742-47-8 30 – 75Petroleum Distillates
CAS number %Chemical name
64742-88-7 0 – 40Mineral spirits
108-88-3 10 – 20Toluene
1330-20-7 < 3Xylene
67-63-0 < 2Propan-2-ol
Components not listed are either non-hazardous or are below reportable limits. All concentrations
are in percent by weight unless ingredient is a gas. Gas concentrations are in percent by volume.
Composition comments
4. First-aid measures
Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a poison
center or doctor/physician if you feel unwell.
Inhalation
Take off immediately all contaminated clothing. Rinse skin with water/shower. If skin irritation
occurs: Get medical advice/attention. Wash contaminated clothing before reuse.
Skin contact
Immediately flush eyes with plenty of water for at least 15 minutes. Remove contact lenses, if
present and easy to do. Continue rinsing. Get medical attention if irritation develops and persists.
Eye contact
Call a physician or poison control center immediately. Rinse mouth. Do not induce vomiting. If
vomiting occurs, keep head low so that stomach content doesn't get into the lungs.
Ingestion
Aspiration may cause pulmonary edema and pneumonitis. May cause drowsiness and dizziness.
Narcosis. Headache. Nausea, vomiting. Diarrhea. Behavioral changes. Decrease in motor
functions. Severe eye irritation. Symptoms may include stinging, tearing, redness, swelling, and
blurred vision. Coughing. Discomfort in the chest. Shortness of breath. Skin irritation. May cause
redness and pain. Prolonged exposure may cause chronic effects.
Most important
symptoms/effects, acute and
delayed
Provide general supportive measures and treat symptomatically. Thermal burns: Flush with water
immediately. While flushing, remove clothes which do not adhere to affected area. Call an
ambulance. Continue flushing during transport to hospital. Keep victim under observation.
Symptoms may be delayed.
Indication of immediate
medical attention and special
treatment needed
Take off all contaminated clothing immediately. If you feel unwell, seek medical advice (show the
label where possible). Ensure that medical personnel are aware of the material(s) involved, and
take precautions to protect themselves. Wash contaminated clothing before reuse.
General information
5. Fire-fighting measures
Water fog. Alcohol resistant foam. Dry chemical powder. Carbon dioxide (CO2).Suitable extinguishing media
Do not use water jet as an extinguisher, as this will spread the fire.Unsuitable extinguishing
media
Vapors may form explosive mixtures with air. Vapors may travel considerable distance to a source
of ignition and flash back. During fire, gases hazardous to health may be formed.
Specific hazards arising from
the chemical
Self-contained breathing apparatus and full protective clothing must be worn in case of fire.Special protective equipment
and precautions for firefighters
White Release Wax Low Viscocity SDS US
944605 Version #: 01 Revision date: - Issue date: 27-June-20182 / 11
In case of fire and/or explosion do not breathe fumes. Move containers from fire area if you can do
so without risk. Cool containers exposed to heat with water spray and remove container, if no risk
is involved.
Fire fighting
equipment/instructions
Use standard firefighting procedures and consider the hazards of other involved materials.Specific methods
Highly flammable liquid and vapor.General fire hazards
6. Accidental release measures
Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Eliminate all
ignition sources (no smoking, flares, sparks, or flames in immediate area). Wear appropriate
protective equipment and clothing during clean-up. Do not breathe mist or vapor. Do not touch
damaged containers or spilled material unless wearing appropriate protective clothing. Ventilate
closed spaces before entering them. Local authorities should be advised if significant spillages
cannot be contained. For personal protection, see section 8 of the SDS.
Personal precautions,
protective equipment and
emergency procedures
Use water spray to reduce vapors or divert vapor cloud drift. Eliminate all ignition sources (no
smoking, flares, sparks, or flames in immediate area). Keep combustibles (wood, paper, oil, etc.)
away from spilled material. Take precautionary measures against static discharge. Use only
non-sparking tools. Prevent product from entering drains.
Large Spills: Stop the flow of material, if this is without risk. Dike the spilled material, where this is
possible. Use a non-combustible material like vermiculite, sand or earth to soak up the product
and place into a container for later disposal. Following product recovery, flush area with water.
Small Spills: Absorb with earth, sand or other non-combustible material and transfer to containers
for later disposal. Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to
remove residual contamination.
Never return spills to original containers for re-use. For waste disposal, see section 13 of the SDS.
Methods and materials for
containment and cleaning up
Avoid release to the environment. Inform appropriate managerial or supervisory personnel of all
environmental releases. Prevent further leakage or spillage if safe to do so. Avoid discharge into
drains, water courses or onto the ground.
Environmental precautions
7. Handling and storage
Obtain special instructions before use. Do not handle until all safety precautions have been read
and understood. Do not handle, store or open near an open flame, sources of heat or sources of
ignition. Protect material from direct sunlight. When using do not smoke. Explosion-proof general
and local exhaust ventilation. Take precautionary measures against static discharges. All
equipment used when handling the product must be grounded. Use non-sparking tools and
explosion-proof equipment. Avoid contact with eyes, skin, and clothing. Avoid prolonged or
repeated contact with skin. Avoid prolonged exposure. Pregnant or breastfeeding women must not
handle this product. Should be handled in closed systems, if possible. Use only in well-ventilated
areas. Wear appropriate personal protective equipment. Wash hands thoroughly after handling.
Avoid release to the environment. Observe good industrial hygiene practices.
Precautions for safe handling
Store locked up. Keep away from heat and sources of ignition. Prevent electrostatic charge
build-up by using common bonding and grounding techniques. Store in a cool, dry place out of
direct sunlight. Store in tightly closed container. Store in a well-ventilated place. Keep in an area
equipped with sprinklers. Store away from incompatible materials (see Section 10 of the SDS).
Conditions for safe storage,
including any incompatibilities
8. Exposure controls/personal protection
Occupational exposure limits
US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000)
ValueComponents Type
PEL 400 mg/m3Mineral spirits (CAS
64742-88-7)
100 ppm
PEL 400 mg/m3Petroleum Distillates (CAS
64742-47-8)
100 ppm
PEL 980 mg/m3Propan-2-ol (CAS 67-63-0)
400 ppm
PEL 435 mg/m3Xylene (CAS 1330-20-7)
100 ppm
White Release Wax Low Viscocity SDS US
944605 Version #: 01 Revision date: - Issue date: 27-June-2018 3 / 11
US. OSHA Table Z-2 (29 CFR 1910.1000)
ValueComponents Type
Ceiling 300 ppmToluene (CAS 108-88-3)
TWA 200 ppm
US. ACGIH Threshold Limit Values
FormValueComponents Type
TWA 200 mg/m3 Non-aerosol.Mineral spirits (CAS
64742-88-7)
STEL 400 ppmPropan-2-ol (CAS 67-63-0)
TWA 200 ppm
TWA 20 ppmToluene (CAS 108-88-3)
STEL 150 ppmXylene (CAS 1330-20-7)
TWA 100 ppm
US. NIOSH: Pocket Guide to Chemical Hazards
ValueComponents Type
TWA 100 mg/m3Mineral spirits (CAS
64742-88-7)
STEL 1225 mg/m3Propan-2-ol (CAS 67-63-0)
500 ppm
TWA 980 mg/m3
400 ppm
STEL 560 mg/m3Toluene (CAS 108-88-3)
150 ppm
TWA 375 mg/m3
100 ppm
Biological limit values
ACGIH Biological Exposure Indices
ValueComponents Determinant Specimen Sampling Time
40 mg/l Acetone Urine *Propan-2-ol (CAS 67-63-0)
0.3 mg/g o-Cresol, with
hydrolysis
Creatinine in
urine
*Toluene (CAS 108-88-3)
0.03 mg/l Toluene Urine *
0.02 mg/l Toluene Blood *
1.5 g/g Methylhippuric
acids
Creatinine in
urine
*Xylene (CAS 1330-20-7)
* - For sampling details, please see the source document.
Exposure guidelines
US - California OELs: Skin designation
Toluene (CAS 108-88-3) Can be absorbed through the skin.
US - Minnesota Haz Subs: Skin designation applies
Toluene (CAS 108-88-3) Skin designation applies.
US ACGIH Threshold Limit Values: Skin designation
Mineral spirits (CAS 64742-88-7) Can be absorbed through the skin.
Explosion-proof general and local exhaust ventilation. Good general ventilation should be used.
Ventilation rates should be matched to conditions. If applicable, use process enclosures, local
exhaust ventilation, or other engineering controls to maintain airborne levels below recommended
exposure limits. If exposure limits have not been established, maintain airborne levels to an
acceptable level. Provide easy access to water supply and eye wash facilities.
Appropriate engineering
controls
White Release Wax Low Viscocity SDS US
944605 Version #: 01 Revision date: - Issue date: 27-June-2018 4 / 11
Individual protection measures, such as personal protective equipment
Wear safety glasses with side shields (or goggles).Eye/face protection
Skin protection
Wear appropriate chemical resistant gloves.Hand protection
Skin protection
Wear appropriate chemical resistant clothing. Use of an impervious apron is recommended.Other
If engineering controls do not maintain airborne concentrations below recommended exposure
limits (where applicable) or to an acceptable level (in countries where exposure limits have not
been established), an approved respirator must be worn.
Respiratory protection
Wear appropriate thermal protective clothing, when necessary.Thermal hazards
When using do not smoke. Always observe good personal hygiene measures, such as washing
after handling the material and before eating, drinking, and/or smoking. Routinely wash work
clothing and protective equipment to remove contaminants.
General hygiene
considerations
9. Physical and chemical properties
Appearance
Liquid.Physical state
Liquid.Form
Blue.Color
Solvent.Odor
Odor threshold Not available.
pH Not available.
Melting point/freezing pointNot available.
Initial boiling point and boiling
range
Not available.
Flash point 39.2 F (4.0 C) Closed Cup (Toluene)
Evaporation rate Not available.
Not applicable.Flammability (solid, gas)
Upper/lower flammability or explosive limits
Flammability limit - lower
(%)
Not available.
Flammability limit - upper
(%)
Not available.
Explosive limit - lower (%)Not available.
Explosive limit - upper (%)Not available.
Vapor pressure Not available.
Vapor density Not available.
Relative density Not available.
Solubility(ies)
Solubility (water) Not available.
Partition coefficient
(n-octanol/water)
Not available.
Auto-ignition temperature Not available.
Decomposition temperature Not available.
Viscosity Not available.
Other information
Not explosive.Explosive properties
Not oxidizing.Oxidizing properties
10. Stability and reactivity
The product is stable and non-reactive under normal conditions of use, storage and transport.Reactivity
Material is stable under normal conditions.Chemical stability
White Release Wax Low Viscocity SDS US
944605 Version #: 01 Revision date: - Issue date: 27-June-2018 5 / 11
No dangerous reaction known under conditions of normal use.Possibility of hazardous
reactions
Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. Avoid
temperatures exceeding the flash point. Contact with incompatible materials.
Conditions to avoid
Strong oxidizers, strong acids, and strong bases.Incompatible materials
Thermal decomposition or combustion may liberate carbon oxides and other toxic gases or vapors.Hazardous decomposition
products
11. Toxicological information
Information on likely routes of exposure
Inhalation May cause drowsiness and dizziness. Prolonged inhalation may be harmful.
Skin contact Causes skin irritation.
Eye contact Causes serious eye irritation.
Ingestion Droplets of the product aspirated into the lungs through ingestion or vomiting may cause a serious
chemical pneumonia.
Symptoms related to the
physical, chemical and
toxicological characteristics
Aspiration may cause pulmonary edema and pneumonitis. May cause drowsiness and dizziness.
Narcosis. Headache. Nausea, vomiting. Diarrhea. Behavioral changes. Decrease in motor
functions. Severe eye irritation. Symptoms may include stinging, tearing, redness, swelling, and
blurred vision. Coughing. Discomfort in the chest. Shortness of breath. Skin irritation. May cause
redness and pain. Prolonged exposure may cause chronic effects.
Information on toxicological effects
Acute toxicity Not expected to be acutely toxic.
Test ResultsComponents Species
Mineral spirits (CAS 64742-88-7)
Dermal
Acute
LD50 Rabbit 3000 mg/kg
Oral
LD50 Rat > 5000 mg/kg
Propan-2-ol (CAS 67-63-0)
Dermal
Acute
LD50 Rabbit 12870 mg/kg
Inhalation
LC50 Rat 72.6 mg/l, 4 hours
Vapor
Oral
LD50 Rat 4710 mg/kg
Toluene (CAS 108-88-3)
Dermal
Acute
LD50 Rabbit 12200 mg/kg
Inhalation
LC50 Rat 28.1 mg/l, 4 Hours
Vapor
Xylene (CAS 1330-20-7)
Oral
Acute
LD50 Rat 3523 mg/kg
Causes skin irritation.Skin corrosion/irritation
Causes serious eye irritation.Serious eye damage/eye
irritation
Respiratory or skin sensitization
Respiratory sensitizationNot a respiratory sensitizer.
White Release Wax Low Viscocity SDS US
944605 Version #: 01 Revision date: – Issue date: 27-June-2018 6 / 11
This product is not expected to cause skin sensitization.Skin sensitization
No data available to indicate product or any components present at greater than 0.1% are
mutagenic or genotoxic.
Germ cell mutagenicity
Carcinogenicity Not classifiable as to carcinogenicity to humans.
IARC Monographs. Overall Evaluation of Carcinogenicity
Propan-2-ol (CAS 67-63-0) 3 Not classifiable as to carcinogenicity to humans.
Toluene (CAS 108-88-3) 3 Not classifiable as to carcinogenicity to humans.
Xylene (CAS 1330-20-7) 3 Not classifiable as to carcinogenicity to humans.
NTP Report on Carcinogens
Not listed.
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1053)
Not regulated.
Suspected of damaging the unborn child.Reproductive toxicity
Specific target organ toxicity –
single exposure
May cause drowsiness and dizziness.
Specific target organ toxicity –
repeated exposure
May cause damage to organs (central nervous system, lung) through prolonged or repeated
exposure.
Aspiration hazard May be fatal if swallowed and enters airways.
Chronic effects May cause damage to organs through prolonged or repeated exposure. Prolonged inhalation may
be harmful.
12. Ecological information
Toxic to aquatic life with long lasting effects.Ecotoxicity
Components Test ResultsSpecies
Petroleum Distillates (CAS 64742-47-8)
Aquatic
LC50Fish 2.9 mg/l, 96 hoursRainbow trout,donaldson trout
(Oncorhynchus mykiss)
Propan-2-ol (CAS 67-63-0)
Aquatic
Acute
LC50Crustacea > 10000 mg/l, 24 hoursDaphnia magna
LC50Fish 9640 mg/l, 96 hoursPimephales promelas
Chronic
EC50Crustacea > 100 mg/l, 21 daysDaphnia magna
NOEC 141 mg/l, 16 daysDaphnia magna
30 mg/l, 21 days
Toluene (CAS 108-88-3)
Aquatic
Acute
EC50Crustacea 11.5 mg/l, 48 hoursDaphnia magna
LC50Fish 5.5 mg/l, 96 hoursOncorhynchus kisutch
Chronic
NOECCrustacea 0.74 mg/l, 7 daysCeriodaphnia dubia
NOECFish 1.4 mg/l, 40 daysOncorhynchus kisutch
Xylene (CAS 1330-20-7)
Aquatic
LC50Fish 2.6 mg/l, 96 hoursRainbow trout,donaldson trout
(Oncorhynchus mykiss)
No data is available on the degradability of any ingredients in the mixture. Persistence and degradability
Bioaccumulative potential
Partition coefficient n-octanol / water (log Kow)
Propan-2-ol (CAS 67-63-0) 0.05
White Release Wax Low Viscocity SDS US
944605 Version #: 01 Revision date: – Issue date: 27-June-2018 7 / 11
Partition coefficient n-octanol / water (log Kow)
Toluene (CAS 108-88-3) 2.73
Xylene (CAS 1330-20-7) 3.12 – 3.2
No data available.Mobility in soil
Other adverse effects The product contains volatile organic compounds which have a photochemical ozone creation
potential.
13. Disposal considerations
Collect and reclaim or dispose in sealed containers at licensed waste disposal site. Incinerate the
material under controlled conditions in an approved incinerator. Do not incinerate sealed
containers. Do not allow this material to drain into sewers/water supplies. Do not contaminate
ponds, waterways or ditches with chemical or used container. If discarded, this product is
considered a RCRA ignitable waste, D001. Dispose of contents/container in accordance with
local/regional/national/international regulations.
Disposal instructions
Dispose in accordance with all applicable regulations.Local disposal regulations
D001: Waste Flammable material with a flash point <140 F
The waste code should be assigned in discussion between the user, the producer and the waste
disposal company.
Hazardous waste code
Dispose of in accordance with local regulations. Empty containers or liners may retain some
product residues. This material and its container must be disposed of in a safe manner (see:
Disposal instructions).
Waste from residues / unused
products
Since emptied containers may retain product residue, follow label warnings even after container is
emptied. Empty containers should be taken to an approved waste handling site for recycling or
disposal.
Contaminated packaging
14. Transport information
DOT
UN1993UN number
Flammable liquids, n.o.s. (Toluene, Mineral spirits)UN proper shipping name
3Class
Transport hazard class(es)
-Subsidiary risk
3Label(s)
IIPacking group
YesMarine pollutant
Environmental hazards
Read safety instructions, SDS and emergency procedures before handling.Special precautions for user
IB2, T7, TP1, TP8, TP28Special provisions
150Packaging exceptions
202Packaging non bulk
242Packaging bulk
IATA
UN1993UN number
Flammable liquid, n.o.s. (Toluene, Mineral spirits)UN proper shipping name
3Class
Transport hazard class(es)
-Subsidiary risk
3Label(s)
IIPacking group
YesEnvironmental hazards
3HERG Code
Read safety instructions, SDS and emergency procedures before handling.Special precautions for user
IMDG
UN1993UN number
FLAMMABLE LIQUID, N.O.S. (TOLUENE, MINERAL SPIRITS)UN proper shipping name
3Class
Transport hazard class(es)
-Subsidiary risk
IIPacking group
YesMarine pollutant
Environmental hazards
White Release Wax Low Viscocity SDS US
944605 Version #: 01 Revision date: - Issue date: 27-June-2018 8 / 11
F-E, S -E EmS
Read safety instructions, SDS and emergency procedures before handling.Special precautions for user
Not applicable.Transport in bulk according to
Annex II of MARPOL 73/78 and
the IBC Code
15. Regulatory information
This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication
Standard, 29 CFR 1910.1200.
US federal regulations
TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D)
Not regulated.
CERCLA Hazardous Substance List (40 CFR 302.4)
Propan-2-ol (CAS 67-63-0) Listed.
Toluene (CAS 108-88-3) Listed.
Xylene (CAS 1330-20-7) Listed.
SARA 304 Emergency release notification
Not regulated.
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1053)
Not regulated.
SARA 302 Extremely hazardous substance
Superfund Amendments and Reauthorization Act of 1986 (SARA)
Not listed.
YesSARA 311/312 Hazardous
chemical
Flammable (gases, aerosols, liquids, or solids)
Skin corrosion or irritation
Serious eye damage or eye irritation
Reproductive toxicity
Specific target organ toxicity (single or repeated exposure)
Aspiration hazard
Classified hazard
categories
SARA 313 (TRI reporting)
Chemical name % by wt.CAS number
Propan-2-ol < 267-63-0
Toluene 10 - 20108-88-3
Xylene < 31330-20-7
Other federal regulations
Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List
Toluene (CAS 108-88-3)
Xylene (CAS 1330-20-7)
Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130)
Not regulated.
Not regulated.Safe Drinking Water Act
(SDWA)
Drug Enforcement Administration (DEA). List 2, Essential Chemicals (21 CFR 1310.02(b) and 1310.04(f)(2) and
Chemical Code Number
Toluene (CAS 108-88-3) 6594
Drug Enforcement Administration (DEA). List 1 & 2 Exempt Chemical Mixtures (21 CFR 1310.12(c))
Toluene (CAS 108-88-3) 35 %WV
DEA Exempt Chemical Mixtures Code Number
Toluene (CAS 108-88-3) 594
FEMA Priority Substances Respiratory Health and Safety in the Flavor Manufacturing Workplace
Propan-2-ol (CAS 67-63-0) Low priority
US state regulations
US. Massachusetts RTK - Substance List
Mineral spirits (CAS 64742-88-7)
Propan-2-ol (CAS 67-63-0)
Toluene (CAS 108-88-3)
White Release Wax Low Viscocity SDS US
944605 Version #: 01 Revision date: - Issue date: 27-June-2018 9 / 11
Xylene (CAS 1330-20-7)
US. New Jersey Worker and Community Right-to-Know Act
Mineral spirits (CAS 64742-88-7)
Petroleum Distillates (CAS 64742-47-8)
Propan-2-ol (CAS 67-63-0)
Toluene (CAS 108-88-3)
Xylene (CAS 1330-20-7)
US. Pennsylvania Worker and Community Right-to-Know Law
Mineral spirits (CAS 64742-88-7)
Propan-2-ol (CAS 67-63-0)
Toluene (CAS 108-88-3)
Xylene (CAS 1330-20-7)
US. Rhode Island RTK
Propan-2-ol (CAS 67-63-0)
Toluene (CAS 108-88-3)
Xylene (CAS 1330-20-7)
California Proposition 65
This product can expose you to chemicals including Benzene, which is known to the State of
California to cause cancer and birth defects or other reproductive harm. For more information go
to www.P65Warnings.ca.gov.
WARNING:
California Proposition 65 - CRT: Listed date/Carcinogenic substance
Benzene (CAS 71-43-2) Listed: February 27, 1987
Cumene (CAS 98-82-8) Listed: April 6, 2010
Ethylbenzene (CAS 100-41-4) Listed: June 11, 2004
Naphthalene (CAS 91-20-3) Listed: April 19, 2002
California Proposition 65 - CRT: Listed date/Developmental toxin
Benzene (CAS 71-43-2) Listed: December 26, 1997
Toluene (CAS 108-88-3) Listed: January 1, 1991
California Proposition 65 - CRT: Listed date/Male reproductive toxin
Benzene (CAS 71-43-2) Listed: December 26, 1997
US. California. Candidate Chemicals List. Safer Consumer Products Regulations (Cal. Code Regs, tit. 22, 69502.3,
subd. (a))
Propan-2-ol (CAS 67-63-0)
Toluene (CAS 108-88-3)
Xylene (CAS 1330-20-7)
International Inventories
Country(s) or region Inventory name On inventory (yes/no)*
Australian Inventory of Chemical Substances (AICS) YesAustralia
Domestic Substances List (DSL) YesCanada
Non-Domestic Substances List (NDSL) NoCanada
Inventory of Existing Chemical Substances in China (IECSC) YesChina
European Inventory of Existing Commercial Chemical
Substances (EINECS)
YesEurope
European List of Notified Chemical Substances (ELINCS) NoEurope
Inventory of Existing and New Chemical Substances (ENCS) NoJapan
Existing Chemicals List (ECL) YesKorea
New Zealand Inventory YesNew Zealand
Philippine Inventory of Chemicals and Chemical Substances
(PICCS)
YesPhilippines
Taiwan Chemical Substance Inventory (TCSI) YesTaiwan
*A "Yes" indicates this product complies with the inventory requirements administered by the governing country(s).
A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing
country(s).
Toxic Substances Control Act (TSCA) Inventory YesUnited States & Puerto Rico
16. Other information, including date of preparation or last revision
27-June-2018Issue date
-Revision date
White Release Wax Low Viscocity SDS US
944605 Version #: 01 Revision date: - Issue date: 27-June-2018 10 / 11
Version # 01
NFPA ratings
02
3
Granitize Products Inc. cannot anticipate all conditions under which this information and its
product, or the products of other manufacturers in combination with its product, may be used. It is
the user s responsibility to ensure safe conditions for handling, storage and disposal of the
product, and to assume liability for loss, injury, damage or expense due to improper use. The
information in the sheet was written based on the best knowledge and experience currently
available.
Disclaimer
White Release Wax Low Viscocity SDS US
944605 Version #: 01 Revision date: - Issue date: 27-June-2018 11 / 11
by | Sep 27, 2025
SAFETY DATA SHEET
1. Identification
TR-110 Seal Wax /TR-111 Slurry Wax (TR-111CS & WRW)Product identifier
Other means of identification
MR110, MR111, MR111-CS & MR-WRWProduct code
Release agent.Recommended use
None known.Recommended restrictions
Manufacturer/Importer/Supplier/Distributor information
TR Industries a Division of Granitize Products Inc.Company name
11022 Vulcan StreetAddress
South Gate, CA 90280-0893
United States
(562) 923-5438Telephone
CHEMTREC: (800) 424-9300Emergency telephone
CHEMTREC International: 00 1-703-527-3887
2. Hazard(s) identification
Category 2Flammable solidsPhysical hazards
Category 3 narcotic effectsSpecific target organ toxicity, single exposureHealth hazards
Not classified.OSHA defined hazards
Label elements
Signal word Warning
Hazard statement Flammable solid. May cause drowsiness or dizziness.
Precautionary statement
Prevention Keep away from heat/sparks/open flames/hot surfaces. – No smoking. Ground/bond container and
receiving equipment. Use explosion-proof electrical/ventilating/lighting// equipment. Avoid
breathing vapors. Use only outdoors or in a well-ventilated area. Wear protective gloves/protective
clothing/eye protection/face protection.
Response If inhaled: Remove person to fresh air and keep comfortable for breathing. In case of fire: Use
water fog, alcohol resistant foam, dry chemical powder, carbon dioxide (CO2) to extinguish. Call a
poison center/doctor if you feel unwell.
Storage Store in a well-ventilated place. Keep container tightly closed. Store locked up.
Disposal Dispose of contents/container in accordance with local/regional/national/international regulations.
Hazard(s) not otherwise
classified (HNOC)
None known.
Supplemental information None.
3. Composition/information on ingredients
Mixtures
CAS numbe
r %Chemical name
64742-48-9Naphtha (petroleum), hydrotreated
heavy
70 – 90
All concentrations are in percent by weight unless ingredient is a gas. Gas concentrations are in
percent by volume. Components not listed are either non-hazardous or are below reportable limits.
Composition comments
TR-110 Seal Wax /TR-111 Slurry Wax (TR-111CS & WRW) SDS US
959665 Version #: 02 Revision date: 20-September-2021 Issue date: 20-September-2021
1 / 7
4. First-aid measures
Remove victim to fresh air and keep at rest in a position comfortable for breathing. If breathing is
difficult, give oxygen. Call a poison center or doctor/physician if you feel unwell.
Inhalation
Immediately flush with plenty of water for at least 15 minutes while removing contaminated clothing
and shoes. Destroy or thoroughly clean contaminated shoes.
Skin contact
Do not rub eyes. Immediately flush eyes with plenty of water for at least 15 minutes. Continue
rinsing. Get medical attention if irritation develops and persists.
Eye contact
If vomiting occurs, keep head low so that stomach content does not get into the lungs. Get medical
attention immediately. Never give anything by mouth to a victim who is unconscious or is having
convulsions.
Ingestion
May cause drowsiness and dizziness. Narcosis. Headache. Nausea, vomiting. May cause redness
and pain.
Most important
symptoms/effects, acute and
delayed
Provide general supportive measures and treat symptomatically. Thermal burns: Flush with water
immediately. While flushing, remove clothes which do not adhere to affected area. Call an
ambulance. Continue flushing during transport to hospital. Keep victim warm. Keep victim under
observation. Symptoms may be delayed.
Indication of immediate
medical attention and special
treatment needed
Take off contaminated clothing and shoes immediately. Ensure that medical personnel are aware
of the material(s) involved, and take precautions to protect themselves. Show this safety data
sheet to the doctor in attendance. Wash contaminated clothing before re-use.
General information
5. Fire-fighting measures
Water fog. Alcohol resistant foam. Carbon dioxide (CO2). Dry chemical powder, carbon dioxide,
sand or earth may be used for small fires only.
Suitable extinguishing media
Do not use water jet as an extinguisher, as this will spread the fire.Unsuitable extinguishing
media
During fire, gases hazardous to health may be formed.Specific hazards arising from
the chemical
Self-contained breathing apparatus and full protective clothing must be worn in case of fire.Special protective equipment
and precautions for firefighters
In case of fire and/or explosion do not breathe fumes. Move containers from fire area if you can do
so without risk.
Fire fighting
equipment/instructions
Use standard firefighting procedures and consider the hazards of other involved materials.Specific methods
Flammable solid.General fire hazards
6. Accidental release measures
Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Remove all
possible sources of ignition in the surrounding area. Wear appropriate protective equipment and
clothing during clean-up. Ensure adequate ventilation. Use appropriate containment to avoid
environmental contamination. Transfer by mechanical means such as vacuum truck to a salvage
tank or other suitable container for recovery or safe disposal. Local authorities should be advised if
significant spillages cannot be contained. For personal protection, see section 8 of the SDS.
Personal precautions,
protective equipment and
emergency procedures
Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Take
precautionary measures against static discharge. Use only non-sparking tools. This product is
miscible in water. Stop the flow of material, if this is without risk.
Large Spills: Wet down with water and dike for later disposal. Shovel the material into waste
container. Following product recovery, flush area with water.
Small Spills: Sweep up or vacuum up spillage and collect in suitable container for disposal.
Never return spills to original containers for re-use. For waste disposal, see section 13 of the SDS.
Methods and materials for
containment and cleaning up
Avoid discharge into drains, water courses or onto the ground. Use appropriate containment to
avoid environmental contamination.
Environmental precautions
TR-110 Seal Wax /TR-111 Slurry Wax (TR-111CS & WRW) SDS US
959665 Version #: 02 Revision date: 20-September-2021 Issue date: 20-September-2021
2 / 7
7. Handling and storage
Provide adequate precautions, such as electrical grounding and bonding, or inert atmospheres. Do
not handle, store or open near an open flame, sources of heat or sources of ignition. Protect
material from direct sunlight. When using do not smoke. Explosion-proof general and local exhaust
ventilation. Minimize fire risks from flammable and combustible materials (including combustible
dust and static accumulating liquids) or dangerous reactions with incompatible materials. Handling
operations that can promote accumulation of static charges include but are not limited to: mixing,
filtering, pumping at high flow rates, splash filling, creating mists or sprays, tank and container
filling, tank cleaning, sampling, gauging, switch loading, vacuum truck operations. Wear
appropriate personal protective equipment. Observe good industrial hygiene practices.
Precautions for safe handling
Store locked up. Keep away from heat, sparks and open flame. Eliminate sources of ignition. Avoid
spark promoters. Ground/bond container and equipment. These alone may be insufficient to
remove static electricity. Store in a cool, dry place out of direct sunlight. Store in tightly closed
container. Store in a well-ventilated place. Keep in an area equipped with sprinklers. Store away
from incompatible materials (see Section 10 of the SDS).
Conditions for safe storage,
including any incompatibilities
8. Exposure controls/personal protection
No exposure limits noted for ingredient(s).Occupational exposure limits
No biological exposure limits noted for the ingredient(s).Biological limit values
Occupational Exposure Limits are not relevant to the current physical form of the product.Exposure guidelines
Explosion-proof general and local exhaust ventilation. Good general ventilation should be used.
Ventilation rates should be matched to conditions. If applicable, use process enclosures, local
exhaust ventilation, or other engineering controls to maintain airborne levels below recommended
exposure limits. If exposure limits have not been established, maintain airborne levels to an
acceptable level.
Appropriate engineering
controls
Individual protection measures, such as personal protective equipment
Wear safety glasses with side shields (or goggles).Eye/face protection
Skin protection
Wear appropriate chemical resistant gloves. Rubber gloves, butyl rubber, neoprene or PVC gloves
are recommended. Other suitable gloves can be recommended by the glove supplier.
Hand protection
Skin protection
Wear appropriate chemical resistant clothing. Use of an impervious apron is recommended.Other
If engineering controls do not maintain airborne concentrations below recommended exposure
limits (where applicable) or to an acceptable level (in countries where exposure limits have not
been established), an approved respirator must be worn. Check with respiratory protective
equipment suppliers.
Respiratory protection
Wear appropriate thermal protective clothing, when necessary.Thermal hazards
When using do not smoke. Always observe good personal hygiene measures, such as washing
after handling the material and before eating, drinking, and/or smoking. Routinely wash work
clothing and protective equipment to remove contaminants.
General hygiene
considerations
9. Physical and chemical properties
Appearance
Solid.Physical state
Solid.Form
Various.Color
Characteristic.Odor
Odor threshold Not available.
pH Not available.
Melting point/freezing pointNot available.
Initial boiling point and boiling
range
309.92 – 404.6 F (154.4 – 207 C)
Flash point 120.02 F (48.9 C)
Evaporation rate 0.1 (Butyl acetate = 1)
Flammable solid.Flammability (solid, gas)
Upper/lower flammability or explosive limits
Explosive limit – lower (%)Not available.
TR-110 Seal Wax /TR-111 Slurry Wax (TR-111CS & WRW) SDS US
959665 Version #: 02 Revision date: 20-September-2021 Issue date: 20-September-2021
3 / 7
Explosive limit – upper (%)Not available.
Vapor pressure Not available.
Vapor density 1.79 (Air = 1)
Relative density 0.81 (Water = 1)
Solubility(ies)
Solubility (water) Negligible in water.
Partition coefficient
(n-octanol/water)
Not available.
Auto-ignition temperature Not available.
Decomposition temperature Not available.
Viscosity Not available.
Other information
Not explosive.Explosive properties
Not oxidizing.Oxidizing properties
Percent volatile 82 %
10. Stability and reactivity
The product is stable and non-reactive under normal conditions of use, storage and transport.Reactivity
Material is stable under normal conditions.Chemical stability
No dangerous reaction known under conditions of normal use.Possibility of hazardous
reactions
Heat, flames and sparks. Avoid temperatures exceeding the flash point. Contact with incompatible
materials.
Conditions to avoid
Strong oxidizing agents.Incompatible materials
No hazardous decomposition products are known.Hazardous decomposition
products
11. Toxicological information
Information on likely routes of exposure
Inhalation May cause drowsiness and dizziness.
Skin contact Repeated exposure may cause skin dryness or cracking.
Eye contac
t Direct contact with eyes may cause temporary irritation.
Ingestion Ingestion may cause irritation and malaise.
Symptoms related to the
physical, chemical and
toxicological characteristics
May cause drowsiness and dizziness. Narcosis. Headache. Nausea, vomiting. May cause
redness and pain.
Information on toxicological effects
Acute toxicit
y Not expected to be acutely toxic.
Repeated exposure may cause skin dryness or cracking.Skin corrosion/irritation
May cause eye irritation on direct contact.Serious eye damage/eye
irritation
Respiratory or skin sensitization
Respiratory sensitizationNot a respiratory sensitizer.
Not a skin sensitizer.Skin sensitization
No data available to indicate product or any components present at greater than 0.1% are
mutagenic or genotoxic.
Germ cell mutagenicity
Carcinogenicity Not classifiable as to carcinogenicity to humans.
IARC Monographs. Overall Evaluation of Carcinogenicity
Naphtha (petroleum), hydrotreated heavy
(CAS 64742-48-9)
3 Not classifiable as to carcinogenicity to humans.
NTP Report on Carcinogens
Not listed.
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1053)
Not listed.
TR-110 Seal Wax /TR-111 Slurry Wax (TR-111CS & WRW) SDS US
959665 Version #: 02 Revision date: 20-September-2021 Issue date: 20-September-2021
4 / 7
This product is not expected to cause reproductive or developmental effects.Reproductive toxicity
Specific target organ toxicity –
single exposure
May cause drowsiness and dizziness.
Specific target organ toxicity –
repeated exposure
Not classified.
Aspiration hazard Not relevant, due to the form of the product.
Chronic effects Prolonged inhalation may be harmful.
Further information None known.
12. Ecological information
The product is not classified as environmentally hazardous. However, this does not exclude the
possibility that large or frequent spills can have a harmful or damaging effect on the environment.
Ecotoxicity
No data is available on the degradability of any ingredients in the mixture. Persistence and degradability
No data available.Bioaccumulative potential
The product is insoluble or slightly soluble in water. Expected to have low mobility in soil.Mobility in soil
Other adverse effects The product contains volatile organic compounds which have a photochemical ozone creation
potential.
13. Disposal considerations
Collect and reclaim or dispose in sealed containers at licensed waste disposal site. Incinerate the
material under controlled conditions in an approved incinerator. Do not incinerate sealed
containers. If discarded, this product is considered a RCRA ignitable waste, D001. Dispose of
contents/container in accordance with local/regional/national/international regulations.
Disposal instructions
Dispose in accordance with all applicable regulations.Local disposal regulations
D001: Waste Flammable material with a flash point <140 F
The waste code should be assigned in discussion between the user, the producer and the waste
disposal company.
Hazardous waste code
Dispose of in accordance with local regulations. Empty containers or liners may retain some
product residues. This material and its container must be disposed of in a safe manner (see:
Disposal instructions).
Waste from residues / unused
products
Since emptied containers may retain product residue, follow label warnings even after container is
emptied. Empty containers should be taken to an approved waste handling site for recycling or
disposal.
Contaminated packaging
14. Transport information
DOT
UN1325UN number
Flammable solids, organic, n.o.s. (Naphtha (petroleum), hydrotreated heavy)UN proper shipping name
4.1Class
Transport hazard class(es)
-Subsidiary risk
4.1Label(s)
IIIPacking group
NoMarine pollutant
Environmental hazards
Read safety instructions, SDS and emergency procedures before handling.Special precautions for user
A1, IB8, IP3, T1, TP33Special provisions
151Packaging exceptions
213Packaging non bulk
240Packaging bulk
IATA
UN1325UN number
Flammable solid, organic, n.o.s. (Naphtha (petroleum), hydrotreated heavy)UN proper shipping name
4.1Class
Transport hazard class(es)
-Subsidiary risk
4.1Label(s)
IIIPacking group
NoEnvironmental hazards
TR-110 Seal Wax /TR-111 Slurry Wax (TR-111CS & WRW) SDS US
959665 Version #: 02 Revision date: 20-September-2021 Issue date: 20-September-2021
5 / 7
3LERG Code
Read safety instructions, SDS and emergency procedures before handling.Special precautions for user
IMDG
UN1325UN number
FLAMMABLE SOLID, ORGANIC, N.O.S. (NAPHTHA (PETROLEUM), HYDROTREATED HEAVY)UN proper shipping name
4.1Class
Transport hazard class(es)
-Subsidiary risk
IIIPacking group
NoMarine pollutant
Environmental hazards
F-A, S-GEmS
Read safety instructions, SDS and emergency procedures before handling.Special precautions for user
Not applicable.Transport in bulk according to
Annex II of MARPOL 73/78 and
the IBC Code
15. Regulatory information
This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication
Standard, 29 CFR 1910.1200.
US federal regulations
TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D)
Not regulated.
CERCLA Hazardous Substance List (40 CFR 302.4)
Not listed.
SARA 304 Emergency release notification
Not regulated.
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1053)
Not listed.
Toxic Substances Control Act (TSCA) All components of the mixture on the TSCA 8(b) inventory are designated
active .
SARA 302 Extremely hazardous substance
Superfund Amendments and Reauthorization Act of 1986 (SARA)
Not listed.
YesSARA 311/312 Hazardous
chemical
Flammable (gases, aerosols, liquids, or solids)
Specific target organ toxicity (single or repeated exposure)
Classified hazard
categories
SARA 313 (TRI reporting)
Not regulated.
Other federal regulations
Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List
Not regulated.
Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130)
Not regulated.
Not regulated.Safe Drinking Water Act
(SDWA)
US state regulations
US. Massachusetts RTK - Substance List
Not regulated.
US. New Jersey Worker and Community Right-to-Know Act
Not listed.
US. Pennsylvania Worker and Community Right-to-Know Law
Naphtha (petroleum), hydrotreated heavy (CAS 64742-48-9)
US. Rhode Island RTK
Not regulated.
TR-110 Seal Wax /TR-111 Slurry Wax (TR-111CS & WRW) SDS US
959665 Version #: 02 Revision date: 20-September-2021 Issue date: 20-September-2021
6 / 7
California Proposition 65
California Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65): This material
is not known to contain any chemicals currently listed as carcinogens or reproductive toxins. For
more information go to www.P65Warnings.ca.gov.
US. California. Candidate Chemicals List. Safer Consumer Products Regulations (Cal. Code Regs, tit. 22, 69502.3,
subd. (a))
Naphtha (petroleum), hydrotreated heavy (CAS 64742-48-9)
International Inventories
Country(s) or region Inventory name On inventory (yes/no)*
YesAustralia Australian Inventory of Industrial Chemicals (AICIS)
YesCanada Domestic Substances List (DSL)
NoCanada Non-Domestic Substances List (NDSL)
YesChina Inventory of Existing Chemical Substances in China (IECSC)
YesEurope European Inventory of Existing Commercial Chemical
Substances (EINECS)
NoEurope European List of Notified Chemical Substances (ELINCS)
NoJapan Inventory of Existing and New Chemical Substances (ENCS)
YesKorea Existing Chemicals List (ECL)
YesNew Zealand New Zealand Inventory
YesPhilippines Philippine Inventory of Chemicals and Chemical Substances
(PICCS)
YesTaiwan Taiwan Chemical Substance Inventory (TCSI)
YesUnited States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory
*A "Yes" indicates that all components of this product comply with the inventory requirements administered by the governing country(s)
A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing
country(s).
16. Other information, including date of preparation or last revision
20-September-2021Issue date
20-September-2021Revision date
Version # 02
NFPA ratings
02
2
TR Industries cannot anticipate all conditions under which this information and its product, or the
products of other manufacturers in combination with its product, may be used. It is the user s
responsibility to ensure safe conditions for handling, storage and disposal of the product, and to
assume liability for loss, injury, damage or expense due to improper use. The information in the
sheet was written based on the best knowledge and experience currently available.
Disclaimer
TR-110 Seal Wax /TR-111 Slurry Wax (TR-111CS & WRW) SDS US
959665 Version #: 02 Revision date: 20-September-2021 Issue date: 20-September-2021
7 / 7
by | Sep 27, 2025
by | Sep 27, 2025
by | Sep 27, 2025
by | Sep 27, 2025
by | Sep 27, 2025
SAFETY DATA SHEET
1. Identification
216 TR Liquid WaxProduct identifier
None.Other means of identification
Liquid wax.Recommended use
None known.Recommended restrictions
Manufacturer/Importer/Supplier/Distributor information
Manufacturer/Supplier Granitize Products, Inc.
11022 Vulcan Street
South Gate, CA 90280-0893 US
Telephone: (562) 923-5438
Emergency CHEMTREC: (800) 424-9300
CHEMTREC International: 00 1-703-527-3887
2. Hazard(s) identification
Category 2Flammable liquidsPhysical hazards
Category 2Skin corrosion/irritationHealth hazards
Category 2ASerious eye damage/eye irritation
Category 2Reproductive toxicity
Category 3 narcotic effectsSpecific target organ toxicity, single exposure
Category 1 (central nervous system)Specific target organ toxicity, repeated
exposure
Category 1Aspiration hazard
Category 3Hazardous to the aquatic environment, acute
hazard
Environmental hazards
Category 3Hazardous to the aquatic environment,
long-term hazard
Not classified.OSHA defined hazards
Label elements
Signal word Danger
Hazard statement Highly flammable liquid and vapor. Causes skin irritation. Causes serious eye irritation. Suspected
of damaging the unborn child. May cause drowsiness or dizziness. Causes damage to organs
(central nervous system) through prolonged or repeated exposure. May be fatal if swallowed and
enters airways. Harmful to aquatic life with long lasting effects.
Precautionary statement
Prevention Obtain special instructions before use. Do not handle until all safety precautions have been read
and understood. Keep away from heat/sparks/open flames/hot surfaces. – No smoking. Keep
container tightly closed. Ground/bond container and receiving equipment. Use explosion-proof
electrical/ventilating/lighting equipment. Use only non-sparking tools. Take precautionary
measures against static discharge. Do not breathe mist or vapor. Wash thoroughly after handling.
Do not eat, drink or smoke when using this product. Use only outdoors or in a well-ventilated area.
Wear protective gloves/protective clothing/eye protection/face protection. Avoid release to the
environment.
216 TR Liquid Wax SDS US
902640 Version #: 03 Revision date: 28-October-2015 Issue date: 12-November-2014
1 / 9
Response If swallowed: Immediately call a poison center/doctor/. Do NOT induce vomiting. If on skin (or
hair): Take off immediately all contaminated clothing. Rinse skin with water/shower. If skin
irritation occurs: Get medical advice/attention. Wash contaminated clothing before reuse. If
inhaled: Remove person to fresh air and keep comfortable for breathing. Call a poison
center/doctor if you feel unwell. If in eyes: Rinse cautiously with water for several minutes.
Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get
medical advice/attention. If exposed or concerned: Get medical advice/attention. In case of fire:
Use water fog, alcohol resistant foam, dry chemical powder, carbon dioxide to extinguish. Collect
spillage.
Storage Store in a well-ventilated place. Keep container tightly closed. Keep cool. Store locked up.
Disposal Dispose of contents/container in accordance with local/regional/national/international regulations.
Hazard(s) not otherwise
classified (HNOC)
None known.
Supplemental information None.
3. Composition/information on ingredients
Mixtures
108-88-3 45 – 80Toluene
CAS number %Chemical name
67-63-0 0 – 20Isopropyl alcohol
95-63-6 5 – 101,2,4- Trimethylbenzene
8052-41-3 5 – 10Stoddard solvent
All concentrations are in percent by weight unless ingredient is a gas. Gas concentrations are in
percent by volume.
Composition comments
4. First-aid measures
Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a POISON
CENTER or doctor/physician if you feel unwell.
Inhalation
Take off immediately all contaminated clothing. Rinse skin with water/shower. If skin irritation
occurs: Get medical advice/attention. Wash contaminated clothing before reuse.
Skin contact
Immediately flush eyes with plenty of water for at least 15 minutes. Remove contact lenses, if
present and easy to do. Continue rinsing. Get medical attention if irritation develops and persists.
Eye contact
Call a physician or poison control center immediately. DO NOT induce vomiting because of danger
of aspirating liquid into lungs. Rinse mouth. If vomiting occurs, keep head low so that stomach
content doesn’t get into the lungs.
Ingestion
Skin irritation. May cause redness and pain. Severe eye irritation. Symptoms may include stinging,
tearing, redness, swelling, and blurred vision. May cause drowsiness and dizziness. Headache.
Nausea, vomiting. Causes damage to organs (central nervous system) through prolonged or
repeated exposure. Behavioral changes. Decrease in motor functions. Narcosis. Aspiration may
cause pulmonary edema and pneumonitis. Swallowing of the liquid, or vomiting as a result, may
result in aspiration into the lungs. Prolonged exposure may cause chronic effects.
Most important
symptoms/effects, acute and
delayed
Provide general supportive measures and treat symptomatically. Keep victim under observation.
Symptoms may be delayed.
Indication of immediate
medical attention and special
treatment needed
Take off all contaminated clothing immediately. If exposed or concerned: get medical
attention/advice. If you feel unwell, seek medical advice (show the label where possible). Ensure
that medical personnel are aware of the material(s) involved, and take precautions to protect
themselves. Show this safety data sheet to the doctor in attendance. Wash contaminated clothing
before reuse.
General information
5. Fire-fighting measures
Water fog. Alcohol resistant foam. Dry chemical powder. Carbon dioxide (CO2).Suitable extinguishing media
Do not use water jet as an extinguisher, as this will spread the fire.Unsuitable extinguishing
media
Vapors may form explosive mixtures with air. Vapors may travel considerable distance to a source
of ignition and flash back. During fire, gases hazardous to health may be formed.
Specific hazards arising from
the chemical
Self-contained breathing apparatus and full protective clothing must be worn in case of fire.Special protective equipment
and precautions for firefighters
216 TR Liquid Wax SDS US
902640 Version #: 03 Revision date: 28-October-2015 Issue date: 12-November-2014
2 / 9
In case of fire and/or explosion do not breathe fumes. Move containers from fire area if you can do
so without risk. Cool containers with flooding quantities of water until well after fire is out.
Fire fighting
equipment/instructions
Use standard firefighting procedures and consider the hazards of other involved materials.Specific methods
Highly flammable liquid and vapor.General fire hazards
6. Accidental release measures
Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Eliminate all
ignition sources (no smoking, flares, sparks, or flames in immediate area). Wear appropriate
protective equipment and clothing during clean-up. Do not breathe mist or vapor. Do not touch
damaged containers or spilled material unless wearing appropriate protective clothing. Ventilate
closed spaces before entering them. Local authorities should be advised if significant spillages
cannot be contained. For personal protection, see section 8 of the SDS.
Personal precautions,
protective equipment and
emergency procedures
Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Keep
combustibles (wood, paper, oil, etc.) away from spilled material. Take precautionary measures
against static discharge. Use only non-sparking tools. Prevent product from entering drains.
Large Spills: Stop the flow of material, if this is without risk. Dike the spilled material, where this is
possible. Use a non-combustible material like vermiculite, sand or earth to soak up the product
and place into a container for later disposal. Following product recovery, flush area with water.
Small Spills: Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to
remove residual contamination.
Never return spills to original containers for re-use. For waste disposal, see section 13 of the SDS.
Methods and materials for
containment and cleaning up
Avoid release to the environment. Inform appropriate managerial or supervisory personnel of all
environmental releases. Prevent further leakage or spillage if safe to do so. Avoid discharge into
drains, water courses or onto the ground.
Environmental precautions
7. Handling and storage
Obtain special instructions before use. Do not handle until all safety precautions have been read
and understood. Do not handle, store or open near an open flame, sources of heat or sources of
ignition. Protect material from direct sunlight. Explosion-proof general and local exhaust ventilation.
Take precautionary measures against static discharges. All equipment used when handling the
product must be grounded. Use non-sparking tools and explosion-proof equipment. Do not breathe
mist or vapor. Do not get in eyes, on skin, or on clothing. Avoid prolonged exposure. When using,
do not eat, drink or smoke. Do not taste or swallow. Pregnant or breastfeeding women must not
handle this product. Should be handled in closed systems, if possible. Wear appropriate personal
protective equipment. Wash hands thoroughly after handling. Avoid release to the environment.
Observe good industrial hygiene practices.
Precautions for safe handling
Store locked up. Keep away from heat, sparks and open flame. Prevent electrostatic charge
build-up by using common bonding and grounding techniques. Store in a cool, dry place out of
direct sunlight. Do not expose to heat or store at temperatures above 120 F/49 C as can may
burst. Store in original tightly closed container. Store in a well-ventilated place. Keep in an area
equipped with sprinklers. Store away from incompatible materials (see Section 10 of the SDS).
Conditions for safe storage,
including any incompatibilities
8. Exposure controls/personal protection
Occupational exposure limits
US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000)
ValueTypeComponents
PEL 980 mg/m3Isopropyl alcohol (CAS
67-63-0)
400 ppm
PEL 2900 mg/m3Stoddard solvent (CAS
8052-41-3)
500 ppm
US. OSHA Table Z-2 (29 CFR 1910.1000)
ValueTypeComponents
Ceiling 300 ppmToluene (CAS 108-88-3)
TWA 200 ppm
216 TR Liquid Wax SDS US
902640 Version #: 03 Revision date: 28-October-2015 Issue date: 12-November-2014
3 / 9
US. ACGIH Threshold Limit Values
ValueTypeComponents
TWA 25 ppm1,2,4- Trimethylbenzene
(CAS 95-63-6)
STEL 400 ppmIsopropyl alcohol (CAS
67-63-0)
TWA 200 ppm
TWA 100 ppmStoddard solvent (CAS
8052-41-3)
TWA 20 ppmToluene (CAS 108-88-3)
US. NIOSH: Pocket Guide to Chemical Hazards
ValueTypeComponents
TWA 125 mg/m31,2,4- Trimethylbenzene
(CAS 95-63-6)
25 ppm
STEL 1225 mg/m3Isopropyl alcohol (CAS
67-63-0)
500 ppm
TWA 980 mg/m3
400 ppm
Ceiling 1800 mg/m3Stoddard solvent (CAS
8052-41-3)
TWA 350 mg/m3
STEL 560 mg/m3Toluene (CAS 108-88-3)
150 ppm
TWA 375 mg/m3
100 ppm
Biological limit values
ACGIH Biological Exposure Indices
Value Sampling TimeDeterminant SpecimenComponents
40 mg/l Acetone Urine *Isopropyl alcohol (CAS
67-63-0)
0.3 mg/g o-Cresol, with
hydrolysis
Creatinine
in urine
*Toluene (CAS 108-88-3)
0.03 mg/l Toluene Urine *
0.02 mg/l Toluene Blood *
* – For sampling details, please see the source document.
Exposure guidelines
US – California OELs: Skin designation
Toluene (CAS 108-88-3) Can be absorbed through the skin.
US – Minnesota Haz Subs: Skin designation applies
Toluene (CAS 108-88-3) Skin designation applies.
Explosion-proof general and local exhaust ventilation. Good general ventilation (typically 10 air
changes per hour) should be used. Ventilation rates should be matched to conditions. If
applicable, use process enclosures, local exhaust ventilation, or other engineering controls to
maintain airborne levels below recommended exposure limits. If exposure limits have not been
established, maintain airborne levels to an acceptable level. Provide easy access to water supply
and eye wash facilities.
Appropriate engineering
controls
Individual protection measures, such as personal protective equipment
Wear safety glasses with side shields (or goggles). Wear face shield if there is risk of splashes.Eye/face protection
Skin protection
Wear appropriate chemical resistant gloves. Be aware that the liquid may penetrate the gloves.
Frequent change is advisable. Suitable gloves can be recommended by the glove supplier.
Hand protection
Skin protection
Wear appropriate chemical resistant clothing. Use of an impervious apron is recommended.Other
216 TR Liquid Wax SDS US
902640 Version #: 03 Revision date: 28-October-2015 Issue date: 12-November-2014
4 / 9
If engineering controls do not maintain airborne concentrations below recommended exposure
limits (where applicable) or to an acceptable level (in countries where exposure limits have not
been established), an approved respirator must be worn. In the United States of America, if
respirators are used, a program should be instituted to assure compliance with OSHA 29 CFR
1910.134.
Respiratory protection
Wear appropriate thermal protective clothing, when necessary.Thermal hazards
Observe any medical surveillance requirements. When using do not smoke. Always observe good
personal hygiene measures, such as washing after handling the material and before eating,
drinking, and/or smoking. Routinely wash work clothing and protective equipment to remove
contaminants.
General hygiene
considerations
9. Physical and chemical properties
Appearance
Liquid.Physical state
Blue liquid.Form
Blue.Color
Solvent odor.Odor
Odor threshold Not available.
pH Not available.
Melting point/freezing pointNot available.
Initial boiling point and boiling
range
Not available.
Flash point 39.2 F (4.0 C) Closed Cup (Toluene)
Evaporation rate Not available.
Not applicable.Flammability (solid, gas)
Upper/lower flammability or explosive limits
Flammability limit – lower
(%)
Not available.
Flammability limit – upper
(%)
Not available.
Explosive limit – lower (%)Not available.
Explosive limit – upper (%)Not available.
Vapor pressure Not available.
Vapor density Not available.
Relative density Not available.
Solubility(ies)
Solubility (water) Not available.
Partition coefficient
(n-octanol/water)
Not available.
Auto-ignition temperature Not available.
Decomposition temperature Not available.
Viscosity Not available.
10. Stability and reactivity
The product is stable and non-reactive under normal conditions of use, storage and transport.Reactivity
Material is stable under normal conditions.Chemical stability
No dangerous reaction known under conditions of normal use.Possibility of hazardous
reactions
Avoid heat, sparks, open flames and other ignition sources. Avoid temperatures exceeding the
flash point. Contact with incompatible materials.
Conditions to avoid
Strong oxidizers, strong acids, and strong bases.Incompatible materials
Thermal decomposition of this product can generate carbon monoxide and carbon dioxide.Hazardous decomposition
products
216 TR Liquid Wax SDS US
902640 Version #: 03 Revision date: 28-October-2015 Issue date: 12-November-2014
5 / 9
11. Toxicological information
Information on likely routes of exposure
Inhalation May cause damage to organs through prolonged or repeated exposure by inhalation. May cause
drowsiness and dizziness. Headache. Nausea, vomiting.
Skin contact Causes skin irritation.
Eye contact Causes serious eye irritation.
Ingestion Droplets of the product aspirated into the lungs through ingestion or vomiting may cause a serious
chemical pneumonia.
Symptoms related to the
physical, chemical and
toxicological characteristics
Skin irritation. May cause redness and pain. Severe eye irritation. Symptoms may include
stinging, tearing, redness, swelling, and blurred vision. May cause drowsiness and dizziness.
Headache. Nausea, vomiting. Causes damage to organs (central nervous system) through
prolonged or repeated exposure. Behavioral changes. Decrease in motor functions. Narcosis.
Swallowing or vomiting of the liquid may result in aspiration into the lungs. Aspiration may cause
pulmonary edema and pneumonitis. Prolonged exposure may cause chronic effects.
Information on toxicological effects
Acute toxicit
y Not expected to be acutely toxic.
Causes skin irritation.Skin corrosion/irritation
Causes serious eye irritation.Serious eye damage/eye
irritation
Respiratory or skin sensitization
Respiratory sensitizationNot a respiratory sensitizer.
This product is not expected to cause skin sensitization.Skin sensitization
No data available to indicate product or any components present at greater than 0.1% are
mutagenic or genotoxic.
Germ cell mutagenicity
Carcinogenicity This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA.
IARC Monographs. Overall Evaluation of Carcinogenicity
Stoddard solvent (CAS 8052-41-3) 3 Not classifiable as to carcinogenicity to humans.
Toluene (CAS 108-88-3) 3 Not classifiable as to carcinogenicity to humans.
NTP Report on Carcinogens
Not listed.
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050)
Not regulated.
Suspected of damaging the unborn child.Reproductive toxicity
Specific target organ toxicity –
single exposure
May cause drowsiness and dizziness.
Specific target organ toxicity –
repeated exposure
Causes damage to organs (central nervous system) through prolonged or repeated exposure.
Aspiration hazard May be fatal if swallowed and enters airways.
Chronic effects Prolonged inhalation may be harmful. Prolonged exposure may cause chronic effects.
Further information Symptoms may be delayed.
12. Ecological information
Harmful to aquatic life with long lasting effects.Ecotoxicity
No data is available on the degradability of this product. Persistence and degradability
No data available on bioaccumulation. Bioaccumulative potential
Partition coefficient n-octanol / water (log Kow)
Stoddard solvent (CAS 8052-41-3) 3.16 – 7.15
Toluene (CAS 108-88-3) 2.73
No data available for this product.Mobility in soil
Other adverse effects The product contains volatile organic compounds which have a photochemical ozone creation
potential.
216 TR Liquid Wax SDS US
902640 Version #: 03 Revision date: 28-October-2015 Issue date: 12-November-2014
6 / 9
13. Disposal considerations
Collect and reclaim or dispose in sealed containers at licensed waste disposal site. Do not allow
this material to drain into sewers/water supplies. Do not contaminate ponds, waterways or ditches
with chemical or used container. Dispose of contents/container in accordance with
local/regional/national/international regulations.
Disposal instructions
Dispose in accordance with all applicable regulations.Local disposal regulations
D001: Waste Flammable material with a flash point <140 F
The waste code should be assigned in discussion between the user, the producer and the waste
disposal company.
Hazardous waste code
Dispose of in accordance with local regulations. Empty containers or liners may retain some
product residues. This material and its container must be disposed of in a safe manner (see:
Disposal instructions).
Waste from residues / unused
products
Since emptied containers may retain product residue, follow label warnings even after container is
emptied. Empty containers should be taken to an approved waste handling site for recycling or
disposal.
Contaminated packaging
14. Transport information
DOT
UN1993UN number
Flammable liquids, n.o.s. (Toluene, Isopropyl alcohol)UN proper shipping name
3Class
Transport hazard class(es)
-Subsidiary risk
3Label(s)
IIPacking group
NoMarine pollutant
Environmental hazards
Read safety instructions, SDS and emergency procedures before handling.Special precautions for user
IB2, T7, TP1, TP8, TP28Special provisions
150Packaging exceptions
202Packaging non bulk
242Packaging bulk
IATA
UN1993UN number
Flammable liquid, n.o.s. (Toluene, Isopropyl alcohol)UN proper shipping name
3Class
Transport hazard class(es)
-Subsidiary risk
3Label(s)
IIPacking group
NoEnvironmental hazards
3HERG Code
Read safety instructions, SDS and emergency procedures before handling.Special precautions for user
IMDG
UN1993UN number
FLAMMABLE LIQUID, N.O.S. (TOLUENE, ISOPROPYL ALCOHOL)UN proper shipping name
3Class
Transport hazard class(es)
-Subsidiary risk
3Label(s)
IIPacking group
NoMarine pollutant
Environmental hazards
F-E, S -E EmS
Read safety instructions, SDS and emergency procedures before handling.Special precautions for user
Not applicable.Transport in bulk according to
Annex II of MARPOL 73/78 and
the IBC Code
216 TR Liquid Wax SDS US
902640 Version #: 03 Revision date: 28-October-2015 Issue date: 12-November-2014
7 / 9
15. Regulatory information
This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication
Standard, 29 CFR 1910.1200.
All components are on the U.S. EPA TSCA Inventory List.
US federal regulations
TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D)
Not regulated.
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050)
Not regulated.
CERCLA Hazardous Substance List (40 CFR 302.4)
Isopropyl alcohol (CAS 67-63-0) LISTED
Toluene (CAS 108-88-3) LISTED
Superfund Amendments and Reauthorization Act of 1986 (SARA)
Immediate Hazard - Yes
Delayed Hazard - Yes
Fire Hazard - Yes
Pressure Hazard - No
Reactivity Hazard - No
Hazard categories
SARA 302 Extremely hazardous substance
Not listed.
YesSARA 311/312 Hazardous
chemical
SARA 313 (TRI reporting)
Chemical name CAS number % by wt.
Toluene 108-88-3 45 - 80
Isopropyl alcohol 67-63-0 0 - 20
1,2,4- Trimethylbenzene 95-63-6 5 - 10
Other federal regulations
Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List
Toluene (CAS 108-88-3)
Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130)
Not regulated.
Not regulated.Safe Drinking Water Act
(SDWA)
Drug Enforcement Administration (DEA). List 2, Essential Chemicals (21 CFR 1310.02(b) and 1310.04(f)(2) and
Chemical Code Number
Toluene (CAS 108-88-3) 6594
Drug Enforcement Administration (DEA). List 1 & 2 Exempt Chemical Mixtures (21 CFR 1310.12(c))
Toluene (CAS 108-88-3) 35 %WV
DEA Exempt Chemical Mixtures Code Number
Toluene (CAS 108-88-3) 594
US state regulations
US. Massachusetts RTK - Substance List
1,2,4- Trimethylbenzene (CAS 95-63-6)
Isopropyl alcohol (CAS 67-63-0)
Stoddard solvent (CAS 8052-41-3)
Toluene (CAS 108-88-3)
US. New Jersey Worker and Community Right-to-Know Act
1,2,4- Trimethylbenzene (CAS 95-63-6)
Isopropyl alcohol (CAS 67-63-0)
Stoddard solvent (CAS 8052-41-3)
Toluene (CAS 108-88-3)
US. Pennsylvania Worker and Community Right-to-Know Law
1,2,4- Trimethylbenzene (CAS 95-63-6)
Isopropyl alcohol (CAS 67-63-0)
Stoddard solvent (CAS 8052-41-3)
Toluene (CAS 108-88-3)
US. Rhode Island RTK
1,2,4- Trimethylbenzene (CAS 95-63-6)
216 TR Liquid Wax SDS US
902640 Version #: 03 Revision date: 28-October-2015 Issue date: 12-November-2014
8 / 9
Isopropyl alcohol (CAS 67-63-0)
Toluene (CAS 108-88-3)
US. California Proposition 65
WARNING: This product contains a chemical known to the State of California to cause birth defects or other reproductive
harm.
US - California Proposition 65 - Carcinogens & Reproductive Toxicity (CRT): Listed substance
Ethylbenzene (CAS 100-41-4)
Toluene (CAS 108-88-3)
International Inventories
Country(s) or region Inventory name On inventory (yes/no)*
Australian Inventory of Chemical Substances (AICS) YesAustralia
Domestic Substances List (DSL) YesCanada
Non-Domestic Substances List (NDSL) NoCanada
Inventory of Existing Chemical Substances in China (IECSC) YesChina
European Inventory of Existing Commercial Chemical
Substances (EINECS)
YesEurope
European List of Notified Chemical Substances (ELINCS) NoEurope
Inventory of Existing and New Chemical Substances (ENCS) YesJapan
Existing Chemicals List (ECL) YesKorea
New Zealand Inventory YesNew Zealand
Philippine Inventory of Chemicals and Chemical Substances
(PICCS)
YesPhilippines
*A "Yes" indicates this product complies with the inventory requirements administered by the governing country(s).
A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing
country(s).
Toxic Substances Control Act (TSCA) Inventory YesUnited States & Puerto Rico
16. Other information, including date of preparation or last revision
12-November-2014Issue date
28-October-2015Revision date
Version # 03
NFPA ratings
02
3
Granitize products Inc. cannot anticipate all conditions under which this information and its
product, or the products of other manufacturers in combination with its product, may be used. It is
the user s responsibility to ensure safe conditions for handling, storage and disposal of the
product, and to assume liability for loss, injury, damage or expense due to improper use. The
information in the sheet was written based on the best knowledge and experience currently
available.
Disclaimer
216 TR Liquid Wax SDS US
902640 Version #: 03 Revision date: 28-October-2015 Issue date: 12-November-2014
9 / 9
by | Sep 27, 2025
by | Sep 27, 2025
SAFETY DATA SHEET
1. Identification
TR-500 One Step PolishProduct identifier
Other means of identification
MR-500 One Step PolishSynonyms
Industrial use. Cleaner Polish / Sealer.Recommended use
None known.Recommended restrictions
Manufacturer/Importer/Supplier/Distributor information
TR Industries a Division of Granitize Products Inc.Company name
11022 Vulcan StreetAddress
South Gate, CA 90280-0893
United States
(562) 923-5438Telephone
CHEMTREC: (800) 424-9300Emergency telephone
CHEMTREC International: 00 1-703-527-3887
2. Hazard(s) identification
Category 3Flammable liquidsPhysical hazards
Category 2Skin corrosion/irritationHealth hazards
Category 2ASerious eye damage/eye irritation
Category 1ACarcinogenicity (inhalation)
Category 3 narcotic effectsSpecific target organ toxicity, single exposure
Category 2 (lungs)Specific target organ toxicity, repeated
exposure (inhalation)
Category 1Aspiration hazard
Not classified.OSHA defined hazards
Label elements
Signal word Danger
Hazard statement Flammable liquid and vapor. May be fatal if swallowed and enters airways. Causes skin irritation.
Causes serious eye irritation. May cause drowsiness or dizziness. May cause cancer by
inhalation. May cause damage to organs (lungs) through prolonged or repeated exposure by
inhalation.
Precautionary statement
Prevention Obtain special instructions before use. Do not handle until all safety precautions have been read
and understood. Keep away from heat/sparks/open flames/hot surfaces. – No smoking. Keep
container tightly closed. Ground/bond container and receiving equipment. Use explosion-proof
electrical/ventilating/lighting equipment. Use only non-sparking tools. Take precautionary
measures against static discharge. Do not breathe mist/vapors. Wash thoroughly after handling.
Use only outdoors or in a well-ventilated area. Wear protective gloves/protective clothing/eye
protection/face protection.
TR-500 One Step Polish SDS US
959672 Version #: 01 Revision date: – Issue date: 20-June-2023
1 / 10
Response If swallowed: Immediately call a poison center/doctor. Do NOT induce vomiting. If on skin (or hair):
Take off immediately all contaminated clothing. Rinse skin with water/shower. If skin irritation
occurs: Get medical advice/attention. If inhaled: Remove person to fresh air and keep comfortable
for breathing. If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses,
if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention.
If exposed or concerned: Get medical advice/attention. Take off contaminated clothing and wash
it before reuse. In case of fire: Use water fog, alcohol resistant foam, dry chemical powder, carbon
dioxide (CO2) to extinguish.
Storage Store in a well-ventilated place. Keep container tightly closed. Keep cool. Store locked up.
Disposal Dispose of contents/container in accordance with local/regional/national/international regulations.
Hazard(s) not otherwise
classified (HNOC)
None known.
Supplemental information None.
3. Composition/information on ingredients
Mixtures
CAS number %Chemical name
64742-48-9Naphtha (petroleum), hydrotreated
heavy
50 – 55
67-63-0Propan-2-ol 1 – 5
14808-60-7Quartz (SiO2) 1 – 5
110-91-8Morpholine 1 – 2
All concentrations are in percent by weight unless otherwise indicated. Components not listed are
either non-hazardous or are below reportable limits.
Composition comments
4. First-aid measures
Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a poison
center or doctor/physician if you feel unwell.
Inhalation
Take off immediately all contaminated clothing. Rinse skin with water/shower. If skin irritation
occurs: Get medical advice/attention.
Skin contact
Immediately flush eyes with plenty of water for at least 15 minutes. Remove contact lenses, if
present and easy to do. Continue rinsing. Get medical attention if irritation develops and persists.
Eye contact
Call a physician or poison control center immediately. Rinse mouth. Do not induce vomiting. If
vomiting occurs, keep head low so that stomach content doesn’t get into the lungs.
Ingestion
Aspiration may cause pulmonary edema and pneumonitis. May cause drowsiness or dizziness.
Headache. Nausea, vomiting. Severe eye irritation. Symptoms may include stinging, tearing,
redness, swelling, and blurred vision. Skin irritation. May cause redness and p
Most important
symptoms/effects, acute and
delayed
Provide general supportive measures and treat symptomatically. Thermal burns: Flush with water
immediately. While flushing, remove clothes which do not adhere to affected area. Call an
ambulance. Continue flushing during transport to hospital. Keep victim und
Indication of immediate
medical attention and special
treatment needed
Take off all contaminated clothing immediately. IF exposed or concerned: Get medical
advice/attention. If you feel unwell, seek medical advice (show the label where possible). Ensure
that medical personnel are aware of the material(s) involved, and take preca
General information
5. Fire-fighting measures
Water fog. Alcohol resistant foam. Dry chemical powder. Carbon dioxide (CO2).Suitable extinguishing media
Do not use water jet as an extinguisher, as this will spread the fire.Unsuitable extinguishing
media
Vapors may form explosive mixtures with air. Vapors may travel considerable distance to a source
of ignition and flash back. During fire, gases hazardous to health may be formed.
Specific hazards arising from
the chemical
Self-contained breathing apparatus and full protective clothing must be worn in case of fire.Special protective equipment
and precautions for firefighters
In case of fire and/or explosion do not breathe fumes. Move containers from fire area if you can do
so without risk.
Fire fighting
equipment/instructions
Use standard firefighting procedures and consider the hazards of other involved materials.Specific methods
Flammable liquid and vapor.General fire hazards
TR-500 One Step Polish SDS US
959672 Version #: 01 Revision date: – Issue date: 20-June-2023
2 / 10
6. Accidental release measures
Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Eliminate all
ignition sources (no smoking, flares, sparks, or flames in immediate area). Wear appropriate
protective equipment and clothing during clean-up. Do not breathe mist/
Personal precautions,
protective equipment and
emergency procedures
Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Keep
combustibles (wood, paper, oil, etc.) away from spilled material. Take precautionary measures
against static discharge. Use only non-sparking tools.
Large Spills
Methods and materials for
containment and cleaning up
Avoid discharge into drains, water courses or onto the ground.Environmental precautions
7. Handling and storage
Obtain special instructions before use. Do not handle until all safety precautions have been read
and understood. Do not handle, store or open near an open flame, sources of heat or sources of
ignition. Protect material from direct sunlight. When using do not
Precautions for safe handling
Keep away from heat, sparks and open flame. Prevent electrostatic charge build-up by using
common bonding and grounding techniques. Store in a cool, dry place out of direct sunlight. Store
in tightly closed container. Store in a well-ventilated place. Store a
Conditions for safe storage,
including any incompatibilities
8. Exposure controls/personal protection
Occupational exposure limits
US. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1053)
ValueComponents Type
TWA 0.05 mg/m3Quartz (SiO2) (CAS
14808-60-7)
US. OSHA Table Z-1 Permissible Exposure Limits (PEL) for Air Contaminants (29 CFR 1910.1000)
ValueComponents Type
PEL 70 mg/m3Morpholine (CAS 110-91-8)
20 ppm
PEL 980 mg/m3Propan-2-ol (CAS 67-63-0)
400 ppm
US. OSHA Table Z-3 Permissible Exposure Limits (PEL) for Mineral Dusts (29 CFR 1910.1000)
FormValueComponents Type
TWA 0.1 mg/m3 Respirable.Quartz (SiO2) (CAS
14808-60-7)
2.4 mppcf Respirable.
US. ACGIH Threshold Limit Values (TLV)
FormValueComponents Type
TWA 20 ppmMorpholine (CAS 110-91-8)
STEL 400 ppmPropan-2-ol (CAS 67-63-0)
TWA 200 ppm
TR-500 One Step Polish SDS US
959672 Version #: 01 Revision date: – Issue date: 20-June-2023
3 / 10
US. ACGIH Threshold Limit Values (TLV)
FormValueComponents Type
TWA 0.025 mg/m3 Respirable fraction.Quartz (SiO2) (CAS
14808-60-7)
NIOSH. Immediately Dangerous to Life or Health (IDLH) Values, as amended
ValueComponents Type
IDLH 2 %Propan-2-ol (CAS 67-63-0)
2000 ppm
IDLH 50 mg/m3Quartz (SiO2) (CAS
14808-60-7)
US. NIOSH: Pocket Guide to Chemical Hazards
FormValueComponents Type
STEL 105 mg/m3Morpholine (CAS 110-91-8)
30 ppm
TWA 70 mg/m3
20 ppm
STEL 1225 mg/m3Propan-2-ol (CAS 67-63-0)
500 ppm
TWA 980 mg/m3
400 ppm
TWA 0.05 mg/m3 Respirable dust.Quartz (SiO2) (CAS
14808-60-7)
Biological limit values
ACGIH Biological Exposure Indices (BEI)
ValueComponents Determinant Specimen Sampling Time
40 mg/l Acetone Urine *Propan-2-ol (CAS 67-63-0)
* – For sampling details, please see the source document.
Exposure guidelines
US – California OELs: Skin designation
Morpholine (CAS 110-91-8) Can be absorbed through the skin.
US – Minnesota Haz Subs: Skin designation applies
Morpholine (CAS 110-91-8) Skin designation applies.
US – Tennessee OELs: Skin designation
Morpholine (CAS 110-91-8) Can be absorbed through the skin.
US ACGIH Threshold Limit Values: Skin designation
Morpholine (CAS 110-91-8) Danger of cutaneous absorption
US. NIOSH: Pocket Guide to Chemical Hazards
Morpholine (CAS 110-91-8) Can be absorbed through the skin.
US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000)
Morpholine (CAS 110-91-8) Can be absorbed through the skin.
Good general ventilation should be used. Ventilation rates should be matched to conditions. If
applicable, use process enclosures, local exhaust ventilation, or other engineering controls to
maintain airborne levels below recommended exposure limits. Explosio
Appropriate engineering
controls
Individual protection measures, such as personal protective equipment
Wear safety glasses with side shields (or goggles).Eye/face protection
Skin protection
Wear appropriate chemical resistant gloves. Neoprene, butyl rubber, nitrile or Viton gloves are
recommended. Be aware that the liquid may penetrate the gloves. Frequent change is advisable.
Hand protection
Skin protection
Wear appropriate chemical resistant clothing. Use of an impervious apron is recommended.Other
TR-500 One Step Polish SDS US
959672 Version #: 01 Revision date: – Issue date: 20-June-2023
4 / 10
If engineering controls do not maintain airborne concentrations below recommended exposure
limits (where applicable) or to an acceptable level (in countries where exposure limits have not
been established), an approved respirator must be worn. Check with resp
Respiratory protection
Wear appropriate thermal protective clothing, when necessary.Thermal hazards
Observe any medical surveillance requirements. When using do not smoke. Always observe good
personal hygiene measures, such as washing after handling the material and before eating,
drinking, and/or smoking. Routinely wash work clothing and protective equipm
General hygiene
considerations
9. Physical and chemical properties
Appearance
Liquid.Physical state
Viscous liquid. Emulsion.Form
White.Color
Solvent.Odor
Odor threshold Not available.
pH Not measured.
Melting point/freezing pointNot measured.
Initial boiling point and boiling
range
Not measured.
Flash point > 100.4 F (> 38 C) (Estimated)
Evaporation rate Not available.
Not applicable.Flammability (solid, gas)
Upper/lower flammability or explosive limits
Explosive limit – lower (%)Not measured.
Explosive limit – upper (%)Not measured.
Vapor pressure Not measured.
Vapor density Not measured.
Relative density Not measured.
Solubility(ies)
Solubility (water) Not measured.
Partition coefficient
(n-octanol/water)
Not applicable, product is a mixture.
Auto-ignition temperature Not measured.
Decomposition temperature Not measured.
Viscosity Not available.
Other information
Density Not measured.
Not explosive.Explosive properties
Kinematic viscosity Not measured.
Not oxidizing.Oxidizing properties
10. Stability and reactivity
The product is stable and non-reactive under normal conditions of use, storage and transport.Reactivity
Material is stable under normal conditions.Chemical stability
No dangerous reaction known under conditions of normal use.Possibility of hazardous
reactions
Avoid heat, sparks, open flames and other ignition sources. Avoid temperatures exceeding the
flash point. Contact with incompatible materials. Protect against direct sunlight.
Conditions to avoid
Strong oxidizing agents. Acids. Chlorine. Fluorine. Isocyanates.Incompatible materials
Thermal decomposition of this product can generate carbon monoxide and carbon dioxide.
Nitrogen oxides. Silicon oxide fumes.
Hazardous decomposition
products
TR-500 One Step Polish SDS US
959672 Version #: 01 Revision date: – Issue date: 20-June-2023
5 / 10
11. Toxicological information
Information on likely routes of exposure
Inhalation May cause damage to organs through prolonged or repeated exposure by inhalation. May cause
drowsiness or dizziness. May cause cancer by inhalation.
Skin contact Causes skin irritation.
Eye contact Causes serious eye irritation.
Ingestion Droplets of the product aspirated into the lungs through ingestion or vomiting may cause a serious
chemical pneumonia.
Symptoms related to the
physical, chemical and
toxicological characteristics
Aspiration may cause pulmonary edema and pneumonitis. May cause drowsiness or dizziness.
Headache. Nausea, vomiting. Severe eye irritation. Symptoms may include stinging, tearing,
redness, swelling, and blurred vision. Skin irritation. May cause redness and pain.
Information on toxicological effects
Acute toxicity Not expected to be acutely toxic.
Test ResultsComponents Species
Morpholine (CAS 110-91-8)
Dermal
Acute
LD50 Rabbit 500 mg/kg
Inhalation
LC50 Rat 8000 ppm, 8 hours
Oral
LD50 Rat 1050 mg/kg
Propan-2-ol (CAS 67-63-0)
Dermal
Acute
LD50 Rabbit 12870 mg/kg
Inhalation
LC50 Rat 72.6 mg/l, 4 hours
Vapor
Oral
LD50 Rat 4710 mg/kg
Quartz (SiO2) (CAS 14808-60-7)
Inhalation
Chronic
LOEC Human 0.0563 mg/m3
Causes skin irritation.Skin corrosion/irritation
Causes serious eye irritation.Serious eye damage/eye
irritation
Respiratory or skin sensitization
Respiratory sensitizationNot a respiratory sensitizer.
This product is not expected to cause skin sensitization.Skin sensitization
No data available to indicate product or any components present at greater than 0.1% are
mutagenic or genotoxic.
Germ cell mutagenicity
Carcinogenicity May cause cancer by inhalation.
IARC Monographs. Overall Evaluation of Carcinogenicity
Morpholine (CAS 110-91-8) 3 Not classifiable as to carcinogenicity to humans.
Naphtha (petroleum), hydrotreated heavy
(CAS 64742-48-9)
3 Not classifiable as to carcinogenicity to humans.
Propan-2-ol (CAS 67-63-0) 3 Not classifiable as to carcinogenicity to humans.
Quartz (SiO2) (CAS 14808-60-7) 1 Carcinogenic to humans.
NTP Report on Carcinogens
Quartz (SiO2) (CAS 14808-60-7) Known To Be Human Carcinogen.
TR-500 One Step Polish SDS US
959672 Version #: 01 Revision date: – Issue date: 20-June-2023
6 / 10
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1053)
Quartz (SiO2) (CAS 14808-60-7) Cancer
This product is not expected to cause reproductive or developmental effects.Reproductive toxicity
Specific target organ toxicity –
single exposure
May cause drowsiness or dizziness.
Specific target organ toxicity –
repeated exposure
May cause damage to organs (lungs) through prolonged or repeated exposure by inhalation.
Aspiration hazard May be fatal if swallowed and enters airways.
Chronic effects Prolonged inhalation may be harmful. May cause damage to organs through prolonged or
repeated exposure. Prolonged exposure may cause chronic effects.
Further information Symptoms may be delayed.
12. Ecological information
Based on available data, the classification criteria are not met for hazardous to the aquatic
environment, acute hazard.
Ecotoxicity
Components Test ResultsSpecies
Propan-2-ol (CAS 67-63-0)
Aquatic
Acute
LC50Crustacea > 10000 mg/l, 24 hoursDaphnia magna
LC50Fish 9640 mg/l, 96 hoursPimephales promelas
Chronic
EC50Crustacea > 100 mg/l, 21 daysDaphnia magna
NOEC 141 mg/l, 16 daysDaphnia magna
30 mg/l, 21 days
No data is available on the degradability of this product.Persistence and degradability
Bioaccumulative potential
Partition coefficient n-octanol / water (log Kow)
Morpholine (CAS 110-91-8) -0.86
Propan-2-ol (CAS 67-63-0) 0.05
No data available for this product.Mobility in soil
Other adverse effects The product contains volatile organic compounds which have a photochemical ozone creation
potential.
13. Disposal considerations
Dispose of this material and its container to hazardous or special waste collection point. Incinerate
the material under controlled conditions in an approved incinerator. Do not incinerate sealed
containers. If discarded, this product is considered a RCRA ign
Disposal instructions
Dispose in accordance with all applicable regulations.Local disposal regulations
D001: Waste Flammable material with a flash point <140 F
The waste code should be assigned in discussion between the user, the producer and the waste
disposal company.
Hazardous waste code
Dispose in accordance with local regulations. Dispose of in accordance with local regulations.
Empty containers or liners may retain some product residues. This material and its container must
be disposed of in a safe manner.
Waste from residues / unused
products
Since emptied containers may retain product residue, follow label warnings even after container is
emptied. Empty containers should be taken to an approved waste handling site for recycling or
disposal.
Contaminated packaging
14. Transport information
DOT
UN1268UN number
Petroleum products, n.o.s.UN proper shipping name
3Class
Transport hazard class(es)
TR-500 One Step Polish SDS US
959672 Version #: 01 Revision date: - Issue date: 20-June-2023
7 / 10
-Subsidiary risk
3Label(s)
IIIPacking group
NoMarine pollutant
Environmental hazards
Read safety instructions, SDS and emergency procedures before handling.Special precautions for user
144, B1, IB3, T4, TP1, TP29Special provisions
150Packaging exceptions
203Packaging non bulk
242Packaging bulk
IATA
UN1268UN number
Petroleum products, n.o.s.UN proper shipping name
3Class
Transport hazard class(es)
-Subsidiary risk
3Label(s)
IIIPacking group
NoEnvironmental hazards
3LERG Code
Read safety instructions, SDS and emergency procedures before handling.Special precautions for user
IMDG
UN1268UN number
PETROLEUM PRODUCTS, N.O.S.UN proper shipping name
3Class
Transport hazard class(es)
-Subsidiary risk
IIIPacking group
NoMarine pollutant
Environmental hazards
F-E, S-EEmS
Read safety instructions, SDS and emergency procedures before handling.Special precautions for user
Not applicable.Transport in bulk according to
Annex II of MARPOL 73/78 and
the IBC Code
15. Regulatory information
This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication
Standard, 29 CFR 1910.1200.
US federal regulations
TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D)
Not regulated.
CERCLA Hazardous Substance List (40 CFR 302.4)
Morpholine (CAS 110-91-8) Listed.
Naphtha (petroleum), hydrotreated heavy
(CAS 64742-48-9)
Listed.
Propan-2-ol (CAS 67-63-0) Listed.
SARA 304 Emergency release notification
Not regulated.
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1053)
Quartz (SiO2) (CAS 14808-60-7) Cancer
lung effects
immune system effects
kidney effects
Toxic Substances Control Act (TSCA) All components of the mixture on the TSCA 8(b) inventory are designated
active .
SARA 302 Extremely hazardous substance
Superfund Amendments and Reauthorization Act of 1986 (SARA)
Not listed.
TR-500 One Step Polish SDS US
959672 Version #: 01 Revision date: - Issue date: 20-June-2023
8 / 10
YesSARA 311/312 Hazardous
chemical
Flammable (gases, aerosols, liquids, or solids)
Skin corrosion or irritation
Serious eye damage or eye irritation
Carcinogenicity
Specific target organ toxicity (single or repeated exposure)
Aspiration hazard
Classified hazard
categories
SARA 313 (TRI reporting)
Chemical name % by wt.
CAS number
Propan-2-ol 1 - 5 67-63-0
Other federal regulations
Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List
Not regulated.
Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130)
Not regulated.
Not regulated.Safe Drinking Water Act
(SDWA)
FEMA Priority Substances Respiratory Health and Safety in the Flavor Manufacturing Workplace
Propan-2-ol (CAS 67-63-0) Low priority
US state regulations
US. Massachusetts RTK - Substance List
Morpholine (CAS 110-91-8)
Propan-2-ol (CAS 67-63-0)
Quartz (SiO2) (CAS 14808-60-7)
US. New Jersey Worker and Community Right-to-Know Act
Morpholine (CAS 110-91-8)
Propan-2-ol (CAS 67-63-0)
Quartz (SiO2) (CAS 14808-60-7)
US. Pennsylvania Worker and Community Right-to-Know Law
Morpholine (CAS 110-91-8)
Naphtha (petroleum), hydrotreated heavy (CAS 64742-48-9)
Propan-2-ol (CAS 67-63-0)
Quartz (SiO2) (CAS 14808-60-7)
US. Rhode Island RTK
Morpholine (CAS 110-91-8)
Propan-2-ol (CAS 67-63-0)
Quartz (SiO2) (CAS 14808-60-7)
California Proposition 65
This product can expose you to chemicals including Benzene, which is known to the State of
California to cause cancer and birth defects or other reproductive harm. For more information go
to www.P65Warnings.ca.gov.
WARNING:
California Proposition 65 - CRT: Listed date/Carcinogenic substance
Benzene (CAS 71-43-2) Listed: February 27, 1987
Quartz (SiO2) (CAS 14808-60-7) Listed: October 1, 1988
California Proposition 65 - CRT: Listed date/Developmental toxin
Benzene (CAS 71-43-2) Listed: December 26, 1997
California Proposition 65 - CRT: Listed date/Male reproductive toxin
Benzene (CAS 71-43-2) Listed: December 26, 1997
US. California. Candidate Chemicals List. Safer Consumer Products Regulations (Cal. Code Regs, tit. 22, 69502.3,
subd. (a))
Naphtha (petroleum), hydrotreated heavy (CAS 64742-48-9)
Propan-2-ol (CAS 67-63-0)
Quartz (SiO2) (CAS 14808-60-7)
International Inventories
Country(s) or region Inventory name On inventory (yes/no)*
YesAustralia Australian Inventory of Industrial Chemicals (AICIS)
YesCanada Domestic Substances List (DSL)
TR-500 One Step Polish SDS US
959672 Version #: 01 Revision date: - Issue date: 20-June-2023
9 / 10
Country(s) or region Inventory name On inventory (yes/no)*
NoCanada Non-Domestic Substances List (NDSL)
YesChina Inventory of Existing Chemical Substances in China (IECSC)
YesEurope European Inventory of Existing Commercial Chemical
Substances (EINECS)
NoEurope European List of Notified Chemical Substances (ELINCS)
YesJapan Inventory of Existing and New Chemical Substances (ENCS)
YesKorea Existing Chemicals List (ECL)
YesNew Zealand New Zealand Inventory
YesPhilippines Philippine Inventory of Chemicals and Chemical Substances
(PICCS)
YesTaiwan Taiwan Chemical Substance Inventory (TCSI)
YesUnited States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory
*A "Yes" indicates that all components of this product comply with the inventory requirements administered by the governing country(s)
A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing
country(s).
16. Other information, including date of preparation or last revision
20-June-2023Issue date
-Revision date
Version # 01
NFPA ratings
02
2
TR Industries cannot anticipate all conditions under which this information and its product, or the
products of other manufacturers in combination with its product, may be used. It is the user s
responsibility to ensure safe conditions for handling, storage
Disclaimer
TR-500 One Step Polish SDS US
959672 Version #: 01 Revision date: - Issue date: 20-June-2023
10 / 10
