by | Sep 27, 2025
AQUA BUFF
GLOSSMASTER
(LC48137)
POLISHING COMPOUND
SAFETY DATA SHEET
Page 1 of 3
PRINTED: 2015-01-23
REVISED: 9/25/2020
Page 1 of 3
Section 1 CHEMICAL PRODUCT and COMPANY IDENTIFICATION
Identification: Product Name:
Recommended use:
Manufacturer:
Emergency telephone:
AQUA BUFF GLOSSMASTER ( LC48137)
Polishing
Osborn
3440 Symmes Road
Hamilton, OH 45015 Telephone: 513-860-3400 ChemTrec (24hr)
800-424-9300
Section 2 HAZARDS IDENTIFICATION
WARNING: Dust may temporarily irritate eyes, skin, and
respiratory system.
Hazard Symbols:
Hazard Classifications:
NFPA HAZARD RATING: Fire: (1, minimal) Health: (2, slight) Reactivity: (1, minimal)
GHS HAZARDS: Fire: (5, minimal) Health: (4, slight) Reactivity: (5, minimal)
National Fire Protection Association (NFPA) Ratings: This information is intended solely for the use of
individuals trained in the NFPA system.
Hazard phrases:
H316, H320, H335: Dust produced during use may cause mild irritation of skin, eyes, and respiratory
tract.
Precautionary Phrases:
P102: Keep out of reach of children.
P261: Avoid breathing dust, may cause respiratory tract irritation.
P264: Wash thoroughly after handling. Avoid skin irritation by wearing protective gloves. If needed
wear eye protection and dust mask.
Emergency Overview: Dust generated in use may cause temporary irritation to skin, eyes, nose, and
respiratory tract. Exposure should be minimized.
Section 3 COMPOSITION / INFORMATION ON INGREDIENTS
CHEMICAL NAME CAS Number EC Number % Range
Aluminum oxide, non-fibrous 1344-28-1 215-691-6 25-35
Water 7732-18-5 231-791-2 50-65
Tallow derivatives Proprietary Proprietary 5-15
Section 4 FIRST AID MEASURES
General: Remove contaminated clothing.
Inhalation: If excessive dust is inhaled, remove to fresh air. Seek medical attention if breathing
difficulties persist.
Eye Contact: Check for and remove any contact lenses. Flush eyes with large amounts of water, cold
water may be used. Seek medical attention if vision difficulties occur.
Skin Contact: Wash contaminated skin with soapy water. Remove contaminated clothing and shoes. Wash
clothing and shoes before reuse.
Ingestion: Immediately rinse mouth and drink plenty of water. DO NOT INDUCE VOMITING unless
directed to do so by medical personnel. Never give anything by mouth to an unconscious person.
Ingestion of small quantities is not expected to produce symptoms. If large quantities are swallowed,
obtain medical help.
Section 5 FIRE FIGHTING MEASURES
SAFETY DATA SHEET
Page 2 of 3
PRINTED: 2015-01-23
REVISED: 9/25/2020
Page 2 of 3
Flash Point & Method: over 370 F (estimated).
Fire Fighting Instructions: Water-based, not flammable in liquid state.
Fire Fighting Equipment: Use self-contained breathing apparatus and turn-out gear.
Hazards during fire-fighting: Heat may produce steam which can cause burns.
Section 6 ACCIDENTAL RELEASE MEASURES
Emergency Action: Isolate spill or leak area immediately.
May make floor slippery while wet. If material cannot be recovered, transfer to waste
container for disposal in local landfill, complying with local, state and federal regulations.
Clean up residues with water.
Section 7 HANDLING AND STORAGE
Handling: Wear protective gloves if skin irritation is experienced. Wash hands before eating. Avoid breathing
dust produced in use.
Storage: Store at room temperature. Avoid freezing and excessive heat.
Section 8 EXPOSURE CONTROL / PERSONAL PROTECTION
CAS Number EC Number OSHA PEL ACGIH TLV
Aluminum oxide, non-
fibrous
1344-28-1 215-691-6 15 mg/m 3 TWA 10 mg/m 3 TWA
Engineering Controls: Provide exhaust ventilation or other engineering controls to keep dust levels
below occupational exposure limits. See section 2 for component exposure guidelines. Local exhaust
ventilation is acceptable.
Respirator: Use a NIOSH-certified dust mask or equivalent.
Hand Protection: Wear gloves.
Eye Protection: Protective eye-wear should be used in dusty environment.
Other Recommendations: Wear protective clothing such as long sleeves. Wash hands after handling.
Section 9 PHYSICAL AND CHEMICAL PROPERTIES
Density approximately 1.5 g/cm3 (25 C / 77 F)
pH 9.5 10.5 Physical State Liquid, thick cream
Boiling Point approximately 212 F / 100 C Solubility in water Dispersible
Freeze Point approximately 32 F / 0 C Appearance Off-white creamy liquid
Vapor Density (Air=1) No data available Odor Mildly chemical
Section 10 STABILITY AND REACTIVITY
General: Stable
Incompatible Materials and Conditions to Avoid: Strong oxidizing agents
Hazardous Polymerization: Will not occur.
Section 11 TOXICOLOGY INFORMATION
No information available on Acute or Chronic ingestion or inhalation toxicity.
No ingredients present above 0.1% which are carcinogenic according to NTP, IARC, or OSHA findings.
Section 12 ECOLOGICAL INFORMATION
All ingredients are inert in the environment, or biodegrade to non-hazardous compounds.
Section 13 DISPOSAL CONSIDERATIONS
RCRA 40 CFR 261 Classifications: not classified as hazardous.
Federal, State, and Local laws governing disposal of material can differ. May be disposed in local
landfill in compliance with proper authorities.
AQUA BUFF
GLOSSMASTER
(LC48137)
POLISHING COMPOUND
SAFETY DATA SHEET
Page 3 of 3
PRINTED: 2015-01-23
REVISED: 9/25/2020
Page 3 of 3
Section 14 TRANSPORTATION INFORMATION
NON-HAZARDOUS MATERIAL; Not regulated for transportation under US DOT, IATA, ICAO, IMDG, Canadian
TDG Regulations, or EU ADR.
Section 15 REGULATORY INFORMATION
US Federal Regulations: SDS complies with the OSHA Hazard Communication Rule, 29 CFR 1910.1200.
CERCLA/Superfund, 40 CFR 117, 302: None of the chemicals are CERCLA hazards
SARA Superfund and Reauthorization Act of 1986 Title III sections 302, 311, 312 and 313:
Section 302 None of the chemicals are extremely hazardous substances (40 CFR 355).
Section 311/312 Material Safety Data Sheet Requirements (40 CFR 370): By our hazard evaluation,
this product may be an eye and skin irritant.
Section 313 List of Toxic Chemicals (40CFC 372): This product contains no chemicals (at level of 1%
or greater) that are found on the 313 list of Toxic Chemicals.
Toxic Substance Control Act (TSCA): All substances are TSCA listed.
Resource Conservation and Recovery Act (RCRA 40 CFR 261) Subpart C & D: Refer to Section 13.
STATE REGULATIONS:
No substances in this mixture are specifically listed by individual state. Other product specific health
and safety data in other sections of the SDS may also be applicable for state requirements. For
details on your regulatory requirements you should contact the appropriate agency in your state.
California Proposition 65: None of the ingredients are on the Proposition 65 list
Canada WHMIS: Not Controlled. All components of this product are included in the Canadian DSL
(Domestic Substances List)
Sections 16 OTHER INFORMATION
LABEL INFORMATION: For Shipping Label information refer to section 14.
Product label warnings are as follows (Comparable CHIP Safety & Risk phrases are noted)
[H303] May be harmful if swallowed.
[P102] Keep out of the reach of children. [P271] Use outdoors or in ventilated area.
[P280] Wear protective gloves and eye protection, to avoid skin and eye irritation.
REVISION DATES SECTIONS REVISED BY
9/25/2020 Company info eb
ABBREVIATIONS USED IN THIS DOCUMENT: NE Not Established, NA Not Applicable, NIF No Information Found
ABRIDGED LIST OF REFERENCES:
Code of Federal Regulations (CFR)
Chemical Guide and OSHA Hazardous Communication Standard
US Department of Labor; Occupational Safety & Health Administration (www.osha.gov)
The Environmental Protection Agency (www.epa.gov)
The Globally Harmonized System of Classification and Labeling of Chemicals (GHS)
Government of Canada: http://canadagazette.gc.ca/news-e.html
To the best of our knowledge, the information contained herein is accurate. However, neither Osborn nor any of its subsidiaries assumes
any liability whatsoever for the accuracy or completeness of the information contained herein. Final determination of suitability of any
material is the sole responsibility of the user. All materials may present unknown hazards and should be used with caution. Although
certain hazards are described herein, we cannot guarantee that these are the only hazards which exist.
AQUA BUFF
GLOSSMASTER
(LC48137)
POLISHING COMPOUND
by | Sep 27, 2025
AQUA BUFF 2000
LC42005
POLISHING COMPOUND
SAFETY DATA SHEET
Page 1 of 3
PRINTED: 9/25/2020
REVISED 09/23/2020
Page 1 of 3
Section 1 CHEMICAL PRODUCT and COMPANY IDENTIFICATION
Identification: Product Name:
Recommended use:
Manufacturer:
Emergency telephone:
AQUA BUFF 2000 ( LC42005 )
Polishing
Osborn
3440 Symmes Road
Hamilton, OH 45015 Telephone:
513-860-3400 ChemTrec (24hr)
800-424-9300
Section 2 HAZARDS IDENTIFICATION
Hazard Classification: Irritant
WARNING: Dust produced in use may temporarily
irritate eyes, skin, and respiratory system.
Hazard Pictogram:
Hazard Classification
NFPA HAZARD RATING: Fire: (1, minimal) Health: (2, minimal) Reactivity: (1, minimal)
HMIS: Fire: (5, minimal) Health: (4, minimal) Reactivity: (5, minimal)
Hazard phrases:
H316, H320, H335: Dust produced during use may cause mild irritation of skin, eyes, and
respiratory tract.
Precautionary Phrases:
P102: Keep out of reach of children.
P261: Avoid breathing dust, may cause respiratory tract irritation.
P264: Wash thoroughly after handling. Avoid skin irritation by wearing protective gloves. If needed
wear eye protection and dust mask.
Section 3 COMPOSITION / INFORMATION ON INGREDIENTS
CHEMICAL NAME CAS Number EC Number % Range
Aluminum oxide, non-fibrous 1344-28-1 215-691-6 40-50
Water 7732-18-5 231-791-2 40-50
Tallow derivatives Proprietary Proprietary 10-20
Section 4 FIRST AID MEASURES
General: Remove contaminated clothing.
Inhalation: If excessive dust is inhaled, remove to fresh air. Seek medical attention if
breathing difficulties persist.
Eye Contact: Check for and remove any contact lenses. Flush eyes with large amounts of
water, cold water may be used. Seek medical attention if vision difficulties
occur.
Skin Contact: Wash contaminated skin with soapy water. Remove contaminated clothing
and shoes. Wash clothing and shoes before reuse.
Ingestion: Immediately rinse mouth and drink plenty of water. DO NOT INDUCE
VOMITING unless directed to do so by medical personnel. Never give
anything by mouth to an unconscious person. Ingestion of small quantities
is not expected to produce symptoms. If large quantities are swallowed,
obtain medical help.
Section 5 FIRE FIGHTING MEASURES
AQUA BUFF 2000
LC42005
POLISHING COMPOUND
SAFETY DATA SHEET
Page 2 of 3
PRINTED: 9/25/2020
REVISED 09/23/2020
Page 2 of 3
Flash Point & Method: over 370 F (estimated).
Fire Fighting Instructions: Water-based, not flammable in liquid state.
Fire Fighting Equipment: Use self-contained breathing apparatus and turn-out gear.
Hazards during fire-fighting: Heat may produce steam which can cause burns.
Section 6 ACCIDENTAL RELEASE MEASURES
Emergency Action: Isolate spill or leak area immediately.
May make floor slippery when wet. If material cannot be recovered, transfer to waste container and dispose in
local landfill, in compliance with local, state and federal regulations. Clean up residual material with
water.
Section 7 HANDLING AND STORAGE
Handling: Wear protective gloves if skin irritation is experienced. Wash hands before eating. Avoid breathing
dust produced in use.
Storage: Store at room temperature. Avoid freezing and excessive heat.
Section 8 EXPOSURE CONTROL / PERSONAL PROTECTION
CAS Number EC Number OSHA PEL ACGIH TLV
Aluminum oxide,
non-fibrous
1344-28-1 215-691-6 15 mg/m 3 TWA 10 mg/m 3 TWA
Engineering Controls: Provide exhaust ventilation or other engineering controls to keep dust levels below
occupational exposure limits. See section 2 for component exposure guidelines. Local exhaust
ventilation is acceptable.
Respirator: Use a NIOSH-certified dust mask or equivalent.
Hand Protection: Wear gloves.
Eye Protection: Protective eye-wear should be used in dusty environment.
Other Recommendations: Wear protective clothing such as long sleeves. Wash hands after handling.
Section 9 PHYSICAL AND CHEMICAL PROPERTIES
Density …approximately 1.5 g/cm3 (25 C / 77 F)
pH ……9.5 10.5 Physical State …….Liquid, thick cream
Boiling Point …. ….approximately 212 F / 100 C Solubility in water …..Dispersible
Freeze Point …. …. approximately 32 F / 0 C Appearance: …..White paste
Vapor Density (Air=1) No data available Odor . …..Mildly chemical
Section 10 STABILITY AND REACTIVITY
General: Stable
Incompatible Materials and Conditions to Avoid: Strong oxidizing agents
Hazardous Polymerization: Will not occur.
Section 11 TOXICOLOGY INFORMATION
No information available on Acute or Chronic ingestion or inhalation toxicity.
No ingredients present above 0.1% which are carcinogenic according to NTP, IARC, or OSHA findings.
Section 12 ECOLOGICAL INFORMATION
All ingredients are inert in the environment, or biodegrade to non-hazardous compounds.
Section 13 DISPOSAL CONSIDERATIONS
RCRA 40 CFR 261 Classifications: not classified as hazardous.
AQUA BUFF 2000
LC42005
POLISHING COMPOUND
SAFETY DATA SHEET
Page 3 of 3
PRINTED: 9/25/2020
REVISED 09/23/2020
Page 3 of 3
Federal, State, and Local laws governing disposal of material can differ. Ensure proper disposal compliance
with proper authorities before disposal.
Section 14 TRANSPORTATION INFORMATION
NON-HAZARDOUS MATERIAL Not regulated for transportation under US DOT, IATA, ICAO, IMDG, Canadian
TDG Regulations, or EU ADR.
Section 15 REGULATORY INFORMATION
US Federal Regulations: SDS complies with the OSHA Hazard Communication Rule, 29 CFR 1910.1200.
CERCLA/Superfund, 40 CFR 117, 302: None of the chemicals are CERCLA hazards
SARA Superfund and Reauthorization Act of 1986 Title III sections 302, 311, 312 and 313:
Section 302 None of the chemicals are extremely hazardous substances (40 CFR 355).
Section 311/312 Material Safety Data Sheet Requirements (40 CFR 370): By our hazard evaluation,
this product may be an eye and skin irritant.
Section 313 List of Toxic Chemicals (40CFC 372): This product contains no chemicals ( at level of 1%
or greater) that are found on the 313 list of Toxic Chemicals.
Toxic Substance Control Act (TSCA): All substances are TSCA listed.
Resource Conservation and Recovery Act (RCRA 40 CFR 261) Subpart C & D:
Refer to Section 13.
STATE REGULATIONS:
No substances in this mixture are specifically listed by individual state. Other product specific health
and safety data in other sections of the SDS may also be applicable for state requirements. For
details on your regulatory requirements you should contact the appropriate agency in your state.
California Proposition 65: None of the ingredients are on the Proposition 65 list
Canada WHMIS: Not Controlled. All components of this product are included in the Canadian DSL
(Domestic Substances List)
Sections 16 OTHER INFORMATION
LABEL INFORMATION: For Shipping Label information refer to section 14
Product label warnings are as follows (Comparable CHIP Safety & Risk phrases are noted):
[H303] May be harmful if swallowed.
[P102] Keep out of the reach of children. [P261] Avoid breathing dust.
[P262] Do not get in eyes or on skin. [P280] Wear protective gloves and eye protection.
REVISION DATES SECTIONS REVISED BY
9/25/2020 Company info eb
ABBREVIATIONS USED IN THIS DOCUMENT: NE Not Established, NA Not Applicable, NIF No Information Found
ABRIDGED LIST OF REFERENCES:
Code of Federal Regulations (CFR)
Chemical Guide and OSHA Hazardous Communication Standard
US Department of Labor; Occupational Safety & Health Administration (www.osha.gov)
The Environmental Protection Agency (www.epa.gov)
The Globally Harmonized System of Classification and Labeling of Chemicals (GHS)
Government of Canada: http://canadagazette.gc.ca/news-e.html
To the best of our knowledge, the information contained herein is accurate. However, neither Osborn nor any of its subsidiaries assumes
any liability whatsoever for the accuracy or completeness of the information contained herein. Final determination of suitability of any
material is the sole responsibility of the user. All materials may present unknown hazards and should be used with caution. Although
certain hazards are described herein, we cannot guarantee that these are the only hazards which exist.
by | Sep 27, 2025
AQUA BUFF 2000
LC42005
POLISHING COMPOUND
SAFETY DATA SHEET
Page 1 of 3
PRINTED: 9/25/2020
REVISED 09/23/2020
Page 1 of 3
Section 1 CHEMICAL PRODUCT and COMPANY IDENTIFICATION
Identification: Product Name:
Recommended use:
Manufacturer:
Emergency telephone:
AQUA BUFF 2000 ( LC42005 )
Polishing
Osborn
3440 Symmes Road
Hamilton, OH 45015 Telephone:
513-860-3400 ChemTrec (24hr)
800-424-9300
Section 2 HAZARDS IDENTIFICATION
Hazard Classification: Irritant
WARNING: Dust produced in use may temporarily
irritate eyes, skin, and respiratory system.
Hazard Pictogram:
Hazard Classification
NFPA HAZARD RATING: Fire: (1, minimal) Health: (2, minimal) Reactivity: (1, minimal)
HMIS: Fire: (5, minimal) Health: (4, minimal) Reactivity: (5, minimal)
Hazard phrases:
H316, H320, H335: Dust produced during use may cause mild irritation of skin, eyes, and
respiratory tract.
Precautionary Phrases:
P102: Keep out of reach of children.
P261: Avoid breathing dust, may cause respiratory tract irritation.
P264: Wash thoroughly after handling. Avoid skin irritation by wearing protective gloves. If needed
wear eye protection and dust mask.
Section 3 COMPOSITION / INFORMATION ON INGREDIENTS
CHEMICAL NAME CAS Number EC Number % Range
Aluminum oxide, non-fibrous 1344-28-1 215-691-6 40-50
Water 7732-18-5 231-791-2 40-50
Tallow derivatives Proprietary Proprietary 10-20
Section 4 FIRST AID MEASURES
General: Remove contaminated clothing.
Inhalation: If excessive dust is inhaled, remove to fresh air. Seek medical attention if
breathing difficulties persist.
Eye Contact: Check for and remove any contact lenses. Flush eyes with large amounts of
water, cold water may be used. Seek medical attention if vision difficulties
occur.
Skin Contact: Wash contaminated skin with soapy water. Remove contaminated clothing
and shoes. Wash clothing and shoes before reuse.
Ingestion: Immediately rinse mouth and drink plenty of water. DO NOT INDUCE
VOMITING unless directed to do so by medical personnel. Never give
anything by mouth to an unconscious person. Ingestion of small quantities
is not expected to produce symptoms. If large quantities are swallowed,
obtain medical help.
Section 5 FIRE FIGHTING MEASURES
AQUA BUFF 2000
LC42005
POLISHING COMPOUND
SAFETY DATA SHEET
Page 2 of 3
PRINTED: 9/25/2020
REVISED 09/23/2020
Page 2 of 3
Flash Point & Method: over 370 F (estimated).
Fire Fighting Instructions: Water-based, not flammable in liquid state.
Fire Fighting Equipment: Use self-contained breathing apparatus and turn-out gear.
Hazards during fire-fighting: Heat may produce steam which can cause burns.
Section 6 ACCIDENTAL RELEASE MEASURES
Emergency Action: Isolate spill or leak area immediately.
May make floor slippery when wet. If material cannot be recovered, transfer to waste container and dispose in
local landfill, in compliance with local, state and federal regulations. Clean up residual material with
water.
Section 7 HANDLING AND STORAGE
Handling: Wear protective gloves if skin irritation is experienced. Wash hands before eating. Avoid breathing
dust produced in use.
Storage: Store at room temperature. Avoid freezing and excessive heat.
Section 8 EXPOSURE CONTROL / PERSONAL PROTECTION
CAS Number EC Number OSHA PEL ACGIH TLV
Aluminum oxide,
non-fibrous
1344-28-1 215-691-6 15 mg/m 3 TWA 10 mg/m 3 TWA
Engineering Controls: Provide exhaust ventilation or other engineering controls to keep dust levels below
occupational exposure limits. See section 2 for component exposure guidelines. Local exhaust
ventilation is acceptable.
Respirator: Use a NIOSH-certified dust mask or equivalent.
Hand Protection: Wear gloves.
Eye Protection: Protective eye-wear should be used in dusty environment.
Other Recommendations: Wear protective clothing such as long sleeves. Wash hands after handling.
Section 9 PHYSICAL AND CHEMICAL PROPERTIES
Density …approximately 1.5 g/cm3 (25 C / 77 F)
pH ……9.5 10.5 Physical State …….Liquid, thick cream
Boiling Point …. ….approximately 212 F / 100 C Solubility in water …..Dispersible
Freeze Point …. …. approximately 32 F / 0 C Appearance: …..White paste
Vapor Density (Air=1) No data available Odor . …..Mildly chemical
Section 10 STABILITY AND REACTIVITY
General: Stable
Incompatible Materials and Conditions to Avoid: Strong oxidizing agents
Hazardous Polymerization: Will not occur.
Section 11 TOXICOLOGY INFORMATION
No information available on Acute or Chronic ingestion or inhalation toxicity.
No ingredients present above 0.1% which are carcinogenic according to NTP, IARC, or OSHA findings.
Section 12 ECOLOGICAL INFORMATION
All ingredients are inert in the environment, or biodegrade to non-hazardous compounds.
Section 13 DISPOSAL CONSIDERATIONS
RCRA 40 CFR 261 Classifications: not classified as hazardous.
AQUA BUFF 2000
LC42005
POLISHING COMPOUND
SAFETY DATA SHEET
Page 3 of 3
PRINTED: 9/25/2020
REVISED 09/23/2020
Page 3 of 3
Federal, State, and Local laws governing disposal of material can differ. Ensure proper disposal compliance
with proper authorities before disposal.
Section 14 TRANSPORTATION INFORMATION
NON-HAZARDOUS MATERIAL Not regulated for transportation under US DOT, IATA, ICAO, IMDG, Canadian
TDG Regulations, or EU ADR.
Section 15 REGULATORY INFORMATION
US Federal Regulations: SDS complies with the OSHA Hazard Communication Rule, 29 CFR 1910.1200.
CERCLA/Superfund, 40 CFR 117, 302: None of the chemicals are CERCLA hazards
SARA Superfund and Reauthorization Act of 1986 Title III sections 302, 311, 312 and 313:
Section 302 None of the chemicals are extremely hazardous substances (40 CFR 355).
Section 311/312 Material Safety Data Sheet Requirements (40 CFR 370): By our hazard evaluation,
this product may be an eye and skin irritant.
Section 313 List of Toxic Chemicals (40CFC 372): This product contains no chemicals ( at level of 1%
or greater) that are found on the 313 list of Toxic Chemicals.
Toxic Substance Control Act (TSCA): All substances are TSCA listed.
Resource Conservation and Recovery Act (RCRA 40 CFR 261) Subpart C & D:
Refer to Section 13.
STATE REGULATIONS:
No substances in this mixture are specifically listed by individual state. Other product specific health
and safety data in other sections of the SDS may also be applicable for state requirements. For
details on your regulatory requirements you should contact the appropriate agency in your state.
California Proposition 65: None of the ingredients are on the Proposition 65 list
Canada WHMIS: Not Controlled. All components of this product are included in the Canadian DSL
(Domestic Substances List)
Sections 16 OTHER INFORMATION
LABEL INFORMATION: For Shipping Label information refer to section 14
Product label warnings are as follows (Comparable CHIP Safety & Risk phrases are noted):
[H303] May be harmful if swallowed.
[P102] Keep out of the reach of children. [P261] Avoid breathing dust.
[P262] Do not get in eyes or on skin. [P280] Wear protective gloves and eye protection.
REVISION DATES SECTIONS REVISED BY
9/25/2020 Company info eb
ABBREVIATIONS USED IN THIS DOCUMENT: NE Not Established, NA Not Applicable, NIF No Information Found
ABRIDGED LIST OF REFERENCES:
Code of Federal Regulations (CFR)
Chemical Guide and OSHA Hazardous Communication Standard
US Department of Labor; Occupational Safety & Health Administration (www.osha.gov)
The Environmental Protection Agency (www.epa.gov)
The Globally Harmonized System of Classification and Labeling of Chemicals (GHS)
Government of Canada: http://canadagazette.gc.ca/news-e.html
To the best of our knowledge, the information contained herein is accurate. However, neither Osborn nor any of its subsidiaries assumes
any liability whatsoever for the accuracy or completeness of the information contained herein. Final determination of suitability of any
material is the sole responsibility of the user. All materials may present unknown hazards and should be used with caution. Although
certain hazards are described herein, we cannot guarantee that these are the only hazards which exist.
by | Sep 27, 2025
AQUA BUFF 2000
LC42005
POLISHING COMPOUND
SAFETY DATA SHEET
Page 1 of 3
PRINTED: 9/25/2020
REVISED 09/23/2020
Page 1 of 3
Section 1 CHEMICAL PRODUCT and COMPANY IDENTIFICATION
Identification: Product Name:
Recommended use:
Manufacturer:
Emergency telephone:
AQUA BUFF 2000 ( LC42005 )
Polishing
Osborn
3440 Symmes Road
Hamilton, OH 45015 Telephone:
513-860-3400 ChemTrec (24hr)
800-424-9300
Section 2 HAZARDS IDENTIFICATION
Hazard Classification: Irritant
WARNING: Dust produced in use may temporarily
irritate eyes, skin, and respiratory system.
Hazard Pictogram:
Hazard Classification
NFPA HAZARD RATING: Fire: (1, minimal) Health: (2, minimal) Reactivity: (1, minimal)
HMIS: Fire: (5, minimal) Health: (4, minimal) Reactivity: (5, minimal)
Hazard phrases:
H316, H320, H335: Dust produced during use may cause mild irritation of skin, eyes, and
respiratory tract.
Precautionary Phrases:
P102: Keep out of reach of children.
P261: Avoid breathing dust, may cause respiratory tract irritation.
P264: Wash thoroughly after handling. Avoid skin irritation by wearing protective gloves. If needed
wear eye protection and dust mask.
Section 3 COMPOSITION / INFORMATION ON INGREDIENTS
CHEMICAL NAME CAS Number EC Number % Range
Aluminum oxide, non-fibrous 1344-28-1 215-691-6 40-50
Water 7732-18-5 231-791-2 40-50
Tallow derivatives Proprietary Proprietary 10-20
Section 4 FIRST AID MEASURES
General: Remove contaminated clothing.
Inhalation: If excessive dust is inhaled, remove to fresh air. Seek medical attention if
breathing difficulties persist.
Eye Contact: Check for and remove any contact lenses. Flush eyes with large amounts of
water, cold water may be used. Seek medical attention if vision difficulties
occur.
Skin Contact: Wash contaminated skin with soapy water. Remove contaminated clothing
and shoes. Wash clothing and shoes before reuse.
Ingestion: Immediately rinse mouth and drink plenty of water. DO NOT INDUCE
VOMITING unless directed to do so by medical personnel. Never give
anything by mouth to an unconscious person. Ingestion of small quantities
is not expected to produce symptoms. If large quantities are swallowed,
obtain medical help.
Section 5 FIRE FIGHTING MEASURES
AQUA BUFF 2000
LC42005
POLISHING COMPOUND
SAFETY DATA SHEET
Page 2 of 3
PRINTED: 9/25/2020
REVISED 09/23/2020
Page 2 of 3
Flash Point & Method: over 370 F (estimated).
Fire Fighting Instructions: Water-based, not flammable in liquid state.
Fire Fighting Equipment: Use self-contained breathing apparatus and turn-out gear.
Hazards during fire-fighting: Heat may produce steam which can cause burns.
Section 6 ACCIDENTAL RELEASE MEASURES
Emergency Action: Isolate spill or leak area immediately.
May make floor slippery when wet. If material cannot be recovered, transfer to waste container and dispose in
local landfill, in compliance with local, state and federal regulations. Clean up residual material with
water.
Section 7 HANDLING AND STORAGE
Handling: Wear protective gloves if skin irritation is experienced. Wash hands before eating. Avoid breathing
dust produced in use.
Storage: Store at room temperature. Avoid freezing and excessive heat.
Section 8 EXPOSURE CONTROL / PERSONAL PROTECTION
CAS Number EC Number OSHA PEL ACGIH TLV
Aluminum oxide,
non-fibrous
1344-28-1 215-691-6 15 mg/m 3 TWA 10 mg/m 3 TWA
Engineering Controls: Provide exhaust ventilation or other engineering controls to keep dust levels below
occupational exposure limits. See section 2 for component exposure guidelines. Local exhaust
ventilation is acceptable.
Respirator: Use a NIOSH-certified dust mask or equivalent.
Hand Protection: Wear gloves.
Eye Protection: Protective eye-wear should be used in dusty environment.
Other Recommendations: Wear protective clothing such as long sleeves. Wash hands after handling.
Section 9 PHYSICAL AND CHEMICAL PROPERTIES
Density …approximately 1.5 g/cm3 (25 C / 77 F)
pH ……9.5 10.5 Physical State …….Liquid, thick cream
Boiling Point …. ….approximately 212 F / 100 C Solubility in water …..Dispersible
Freeze Point …. …. approximately 32 F / 0 C Appearance: …..White paste
Vapor Density (Air=1) No data available Odor . …..Mildly chemical
Section 10 STABILITY AND REACTIVITY
General: Stable
Incompatible Materials and Conditions to Avoid: Strong oxidizing agents
Hazardous Polymerization: Will not occur.
Section 11 TOXICOLOGY INFORMATION
No information available on Acute or Chronic ingestion or inhalation toxicity.
No ingredients present above 0.1% which are carcinogenic according to NTP, IARC, or OSHA findings.
Section 12 ECOLOGICAL INFORMATION
All ingredients are inert in the environment, or biodegrade to non-hazardous compounds.
Section 13 DISPOSAL CONSIDERATIONS
RCRA 40 CFR 261 Classifications: not classified as hazardous.
AQUA BUFF 2000
LC42005
POLISHING COMPOUND
SAFETY DATA SHEET
Page 3 of 3
PRINTED: 9/25/2020
REVISED 09/23/2020
Page 3 of 3
Federal, State, and Local laws governing disposal of material can differ. Ensure proper disposal compliance
with proper authorities before disposal.
Section 14 TRANSPORTATION INFORMATION
NON-HAZARDOUS MATERIAL Not regulated for transportation under US DOT, IATA, ICAO, IMDG, Canadian
TDG Regulations, or EU ADR.
Section 15 REGULATORY INFORMATION
US Federal Regulations: SDS complies with the OSHA Hazard Communication Rule, 29 CFR 1910.1200.
CERCLA/Superfund, 40 CFR 117, 302: None of the chemicals are CERCLA hazards
SARA Superfund and Reauthorization Act of 1986 Title III sections 302, 311, 312 and 313:
Section 302 None of the chemicals are extremely hazardous substances (40 CFR 355).
Section 311/312 Material Safety Data Sheet Requirements (40 CFR 370): By our hazard evaluation,
this product may be an eye and skin irritant.
Section 313 List of Toxic Chemicals (40CFC 372): This product contains no chemicals ( at level of 1%
or greater) that are found on the 313 list of Toxic Chemicals.
Toxic Substance Control Act (TSCA): All substances are TSCA listed.
Resource Conservation and Recovery Act (RCRA 40 CFR 261) Subpart C & D:
Refer to Section 13.
STATE REGULATIONS:
No substances in this mixture are specifically listed by individual state. Other product specific health
and safety data in other sections of the SDS may also be applicable for state requirements. For
details on your regulatory requirements you should contact the appropriate agency in your state.
California Proposition 65: None of the ingredients are on the Proposition 65 list
Canada WHMIS: Not Controlled. All components of this product are included in the Canadian DSL
(Domestic Substances List)
Sections 16 OTHER INFORMATION
LABEL INFORMATION: For Shipping Label information refer to section 14
Product label warnings are as follows (Comparable CHIP Safety & Risk phrases are noted):
[H303] May be harmful if swallowed.
[P102] Keep out of the reach of children. [P261] Avoid breathing dust.
[P262] Do not get in eyes or on skin. [P280] Wear protective gloves and eye protection.
REVISION DATES SECTIONS REVISED BY
9/25/2020 Company info eb
ABBREVIATIONS USED IN THIS DOCUMENT: NE Not Established, NA Not Applicable, NIF No Information Found
ABRIDGED LIST OF REFERENCES:
Code of Federal Regulations (CFR)
Chemical Guide and OSHA Hazardous Communication Standard
US Department of Labor; Occupational Safety & Health Administration (www.osha.gov)
The Environmental Protection Agency (www.epa.gov)
The Globally Harmonized System of Classification and Labeling of Chemicals (GHS)
Government of Canada: http://canadagazette.gc.ca/news-e.html
To the best of our knowledge, the information contained herein is accurate. However, neither Osborn nor any of its subsidiaries assumes
any liability whatsoever for the accuracy or completeness of the information contained herein. Final determination of suitability of any
material is the sole responsibility of the user. All materials may present unknown hazards and should be used with caution. Although
certain hazards are described herein, we cannot guarantee that these are the only hazards which exist.
by | Sep 27, 2025
AQUA BUFF 1000W
LS51003
POLISHING COMPOUND
SAFETY DATA SHEET
Page 1 of 3
PRINTED: 2015-01-23
REVISED:09/23/2020 9/25/2020 11:17 AM
Page 1 of 3
Section 1 CHEMICAL PRODUCT and COMPANY IDENTIFICATION
Identification: Product Name:
Recommended use:
Manufacturer:
Emergency telephone:
AQUA BUFF 1000W (L S51003)
Polishing
Osborn
3440 Symmes Road
Hamilton, OH 45015
Telephone: 513-860-3400
ChemTrec (24hr) 800-424-9300
Section 2 HAZARDS IDENTIFICATION
Hazard Classification: Irritant
WARNING: Dust may temporarily irritate eyes, skin, and
respiratory system.
Hazard Symbols:
Hazard Classifications:
NFPA HAZARD RATING: Fire: (1, minimal) Health: (2, slight) Reactivity: (1, minimal)
GHS HAZARDS: Fire: (5, minimal) Health: (4, slight) Reactivity: (5, minimal)
National Fire Protection Association (NFPA) Ratings: This information is intended solely for the use of
individuals trained in the NFPA system.
Hazard phrases:
H316, H320, H335: Dust produced during use may cause mild irritation of skin, eyes, and respiratory
tract.
Precautionary Phrases:
P102: Keep out of reach of children.
P261: Avoid breathing dust, may cause respiratory tract irritation
P264: Wash thoroughly after handling. Avoid skin irritation by wearing protective gloves. If needed
wear eye protection and dust mask.
Emergency Overview: Dust generated in use may cause temporary irritation to skin, eyes, nose,
and respiratory tract. Exposure should be minimized.
Section 3 COMPOSITION / INFORMATION ON INGREDIENTS
CHEMICAL NAME CAS Number EC Number % Range
Aluminum oxide, non-fibrous 1344-28-1 215-691-6 40-50
Water 7732-18-5 231-791-2 40-50
Tallow derivatives Proprietary Proprietary 10-15
Section 4 FIRST AID MEASURES
General: Remove contaminated clothing.
Inhalation: If excessive dust is inhaled, remove to fresh air. Seek medical attention if breathing
difficulties persist.
Eye Contact: Check for and remove any contact lenses. Flush eyes with large amounts of water, cold
water may be used. Seek medical attention if vision difficulties occur.
Skin Contact: Wash contaminated skin with soapy water. Remove contaminated clothing and shoes. Wash
clothing and shoes before reuse.
Ingestion: Immediately rinse mouth and drink plenty of water. DO NOT INDUCE VOMITING unless
directed to do so by medical personnel. Never give anything by mouth to an unconscious person.
Ingestion of small quantities is not expected to produce symptoms. If large quantities are swallowed,
obtain medical help.
AQUA BUFF 1000W
LS51003
POLISHING COMPOUND
SAFETY DATA SHEET
Page 2 of 3
PRINTED: 2015-01-23
REVISED:09/23/2020 9/25/2020 11:17 AM
Page 2 of 3
Section 5 FIRE FIGHTING MEASURES
Flash Point & Method: over 370 F (estimated).
Fire Fighting Instructions: Water-based, not flammable in liquid state.
Fire Fighting Equipment: Use self-contained breathing apparatus and turn-out gear.
Hazards during fire-fighting: Heat may produce steam which can cause burns.
Section 6 ACCIDENTAL RELEASE MEASURES
Emergency Action: Isolate spill or leak area immediately.
May make floor slippery while wet. If material cannot be recovered, transfer to waste container for
disposal in local landfill, complying with local, state and federal regulations. Clean up residues with water.
Section 7 HANDLING AND STORAGE
Handling: Wear protective gloves if skin irritation is experienced. Wash hands before eating. Avoid
breathing dust produced in use.
Storage: Store at room temperature. Avoid freezing and excessive heat.
Section 8 EXPOSURE CONTROL / PERSONAL PROTECTION
CAS Number EC Number OSHA PEL ACGIH TLV
Aluminum oxide, non-
fibrous
1344-28-1 215-691-6 15 mg/m 3 TWA 10 mg/m 3 TWA
Engineering Controls: Provide exhaust ventilation or other engineering controls to keep dust levels below
occupational exposure limits. See section 2 for component exposure guidelines. Local
exhaust ventilation is acceptable.
Respirator: Use a NIOSH-certified dust mask or equivalent.
Hand Protection: Wear gloves.
Eye Protection: Protective eye-wear should be used in dusty environment.
Other Recommendations: Wear protective clothing such as long sleeves. Wash hands after handling.
Section 9 PHYSICAL AND CHEMICAL PROPERTIES
Density approximately 1.5 g/cm3 (25 C / 77 F)
pH 9.5 10.5 Physical State Liquid, thick cream
Boiling Point approximately 212 F / 100 C Solubility in water Dispersible
Freeze Point approximately 32 F / 0 C Appearance Blue creamy paste
Vapor Density (Air=1) No data available Odor Mildly chemical
Section 10 STABILITY AND REACTIVITY
General: Stable
Incompatible Materials and Conditions to Avoid: Strong oxidizing agents
Hazardous Polymerization: Will not occur.
Section 11 TOXICOLOGY INFORMATION
No information available on Acute or Chronic ingestion or inhalation toxicity.
No ingredients present above 0.1% which are carcinogenic according to NTP, IARC, or OSHA findings.
Section 12 ECOLOGICAL INFORMATION
All ingredients are inert in the environment, or biodegrade to non-hazardous compounds.
Section 13 DISPOSAL CONSIDERATIONS
RCRA 40 CFR 261 Classifications: not classified as hazardous.
Federal, State, and Local laws governing disposal of material can differ. May be disposed in local
landfill in compliance with proper authorities.
AQUA BUFF 1000W
LS51003
POLISHING COMPOUND
SAFETY DATA SHEET
Page 3 of 3
PRINTED: 2015-01-23
REVISED:09/23/2020 9/25/2020 11:17 AM
Page 3 of 3
Section 14 TRANSPORTATION INFORMATION
NON-HAZARDOUS MATERIAL Not regulated for transportation under US DOT, IATA, ICAO, IMDG, Canadian
TDG Regulations, or EU ADR.
Section 15 REGULATORY INFORMATION
US Federal Regulations: SDS complies with the OSHA Hazard Communication Rule, 29 CFR 1910.1200.
CERCLA/Superfund, 40 CFR 117, 302: None of the chemicals are CERCLA hazards
SARA Superfund and Reauthorization Act of 1986 Title III sections 302, 311, 312 and 313:
Section 302 None of the chemicals are extremely hazardous substances (40 CFR 355).
Section 311/312 Material Safety Data Sheet Requirements (40 CFR 370): By our hazard evaluation,
this product may be an eye and skin irritant.
Section 313 List of Toxic Chemicals (40CFC 372): This product contains no chemicals (at level of 1%
or greater) that are found on the 313 list of Toxic Chemicals.
Toxic Substance Control Act (TSCA): All substances are TSCA listed.
Resource Conservation and Recovery Act (RCRA 40 CFR 261) Subpart C & D: Refer to Section 13.
STATE REGULATIONS:
No substances in this mixture are specifically listed by individual state. Other product specific health
and safety data in other sections of the SDS may also be applicable for state requirements. For
details on your regulatory requirements you should contact the appropriate agency in your state.
California Proposition 65: None of the ingredients are on the Proposition 65 list
Canada WHMIS: Not Controlled. All components of this product are included in the Canadian DSL
(Domestic Substances List)
Sections 16 OTHER INFORMATION
LABEL INFORMATION: For Shipping Label information refer to section 14
Product label warnings are as follows (Comparable CHIP Safety & Risk phrases are noted):
[H303] May be harmful if swallowed.
[P102] Keep out of the reach of children. [P271] Use outdoors or in ventilated area.
[P280] Wear protective gloves and eye protection, to avoid skin and eye irritation.
REVISION DATES SECTIONS REVISED BY
9/25/2020 Company info eb
ABBREVIATIONS USED IN THIS DOCUMENT: NE Not Established, NA Not Applicable, NIF No Information Found
ABRIDGED LIST OF REFERENCES:
Code of Federal Regulations (CFR)
Chemical Guide and OSHA Hazardous Communication Standard
US Department of Labor; Occupational Safety & Health Administration (www.osha.gov)
The Environmental Protection Agency (www.epa.gov)
The Globally Harmonized System of Classification and Labeling of Chemicals (GHS)
Government of Canada: http://canadagazette.gc.ca/news-e.html
To the best of our knowledge, the information contained herein is accurate. However, neither Osborn nor any of its subsidiaries assumes
any liability whatsoever for the accuracy or completeness of the information contained herein. Final determination of suitability of any
material is the sole responsibility of the user. All materials may present unknown hazards and should be used with caution. Although
certain hazards are described herein, we cannot guarantee that these are the only hazards which exist.
by | Sep 27, 2025
AQUABUFF 1000W
Safety Data Sheet
according to Regulation (EC) No. 453/2010
Date of issue: 08/01/2016 Revision date: 18/02/2016 Supersedes: 10/09/2014 Version:
18/02/2016 EN (English US) 1/6
SECTION 1: Identification of the substance/mixture and of the company/undertaking
1.1. Product identifier
Product form :Mixture
Trade name :AQUABUFF 1000W
CAS No :mixture
Product code :37AB1000W
Type of product :Coating
Formula :na
Product group :Trade product
1.2. Relevant identified uses of the substance or mixture and uses advised against
1.2.1.Relevant identified uses
Industrial/Professional use spec :Industrial
For professional use only
Use of the substance/mixture :POLISHING COMPOUND
1.2.2.Uses advised against
No additional information available
1.3. Details of the supplier of the safety data sheet
1.4. Emergency telephone number
Emergency number :773.924.1515
SECTION 2: Hazards identification
2.1. Classification of the substance or mixture
Classification according to Regulation (EC) No. 1272/2008 [CLP]Show CLP information + DPD classification in section 2.1
Not classified
Classification according to Directive 67/548/EEC [DSD] or 1999/45/EC [DPD]
Not classified
Adverse physicochemical, human health and environmental effects
No additional information available
2.2. Label elements
Labeling according to Regulation (EC) No. 1272/2008 [CLP]
No labeling applicable
2.3. Other hazards
No additional information available
SECTION 3: Composition/Information on ingredients
3.1. Substance
Not applicable
3.2. Mixture
This mixture does not contain any substances to be mentioned according to the criteria of section 3.2 of REACH annex II
AQUABUFF 1000W
Safety Data Sheet
according to Regulation (EC) No. 453/2010
18/02/2016 EN (English US) 2/6
SECTION 4: First aid measures
4.1. Description of first aid measures
First-aid measures general :Never give anything by mouth to an unconscious person. If you feel unwell, seek medical
advice (show the label where possible).
First-aid measures after inhalation :Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a
POISON CENTER or doctor/physician if you feel unwell. Allow victim to breathe fresh air. Allow
the victim to rest.
First-aid measures after skin contact :Wash with plenty of soap and water. Wash contaminated clothing before reuse. If skin irritation
occurs: wash throughly for five minutes. seek medical attention. Get medical advice/attention.
Specific treatment (see seek medical attention. on this label). Remove affected clothing and
wash all exposed skin area with mild soap and water, followed by warm water rinse.
First-aid measures after eye contact :Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to
do. Continue rinsing. If eye irritation persists: SEEK IMMEDIATE MEDICAL ATTENTION. Get
medical advice/attention. Rinse immediately with plenty of water. Obtain medical attention if
pain, blinking or redness persist.
First-aid measures after ingestion :Rinse mouth. Do NOT induce vomiting. Obtain emergency medical attention.
4.2. Most important symptoms and effects, both acute and delayed
Symptoms/injuries :May cause genetic defects (avoid skin contact and inhalation.). May cause cancer (avoid skin
contact and inhalation.). Not expected to present a significant hazard under anticipated
conditions of normal use.
Symptoms/injuries after inhalation :Danger of serious damage to health by prolonged exposure through inhalation. Harmful if
inhaled.
Symptoms/injuries after skin contact :Causes skin irritation.
Symptoms/injuries after eye contact :Causes serious eye irritation.
4.3. Indication of any immediate medical attention and special treatment needed
No additional information available
SECTION 5: Firefighting measures
5.1. Extinguishing media
Suitable extinguishing media :Foam. Dry powder. Carbon dioxide. Water spray. Sand.
Unsuitable extinguishing media :Do not use a heavy water stream.
5.2. Special hazards arising from the substance or mixture
Fire hazard :Highly flammable liquid and vapor.
Reactivity :No reactivity hazard other than the effects described in sub-sections below.
5.3. Advice for firefighters
Firefighting instructions :Use water spray or fog for cooling exposed containers. Exercise caution when fighting any
chemical fire. Prevent fire-fighting water from entering environment.
Protection during firefighting :Do not enter fire area without proper protective equipment, including respiratory protection.
SECTION 6: Accidental release measures
6.1. Personal precautions, protective equipment and emergency procedures
6.1.1.For non-emergency personnel
Protective equipment :Gloves. Protective goggles. Protective clothing.
Emergency procedures :Evacuate unnecessary personnel.
6.1.2.For emergency responders
Protective equipment :Equip cleanup crew with proper protection.
Emergency procedures :Ventilate area.
6.2. Environmental precautions
Prevent entry to sewers and public waters. Notify authorities if liquid enters sewers or public waters.
6.3. Methods and material for containment and cleaning up
For containment :Dam up the liquid spill. Contain released substance, pump into suitable containers.
Methods for cleaning up :Soak up spills with inert solids, such as clay or diatomaceous earth as soon as possible. Collect
spillage. Store away from other materials.
6.4. Reference to other sections
See Heading 8. Exposure controls and personal protection.
AQUABUFF 1000W
Safety Data Sheet
according to Regulation (EC) No. 453/2010
18/02/2016 EN (English US) 3/6
SECTION 7: Handling and storage
7.1. Precautions for safe handling
Precautions for safe handling :Use only outdoors or in a well-ventilated area. Avoid breathing DUST, FUMES, MIST, OR
VAPORS. Obtain special instructions before use. Do not handle until all safety precautions
have been read and understood. Eliminate all ignition sources if safe to do so. Wash hands and
other exposed areas with mild soap and water before eating, drinking or smoking and when
leaving work. Provide good ventilation in process area to prevent formation of vapor.
Hygiene measures :Wash HANDS thoroughly after handling.
7.2. Conditions for safe storage, including any incompatibilities
Storage conditions :Keep in fireproof place. Keep only in the original container in a cool, well ventilated place away
from : Keep container closed when not in use.
Incompatible products :Strong bases. Strong acids.
Incompatible materials :Sources of ignition. Direct sunlight.
7.3. Specific end use(s)
No additional information available
SECTION 8: Exposure controls/personal protection
8.1. Control parameters
No additional information available
8.2. Exposure controls
Appropriate engineering controls :Ensure exposure is below occupational exposure limits (where available).
Personal protective equipment :Avoid all unnecessary exposure.
Hand protection :Wear protective gloves.
Eye protection :Chemical goggles or safety glasses.
Skin and body protection :Wear suitable protective clothing.
Respiratory protection :Wear appropriate mask.
Other information :Do not eat, drink or smoke during use.
SECTION 9: Physical and chemical properties
9.1. Information on basic physical and chemical properties
Physical state :Liquid
Color :white.
Odor :characteristic.
Odor threshold :No data available
pH :No data available
Relative evaporation rate (butyl acetate=1):No data available
Melting point :No data available
Freezing point :0 C
Boiling point :>= 100 C
Flash point :>= C
Auto-ignition temperature :No data available
Decomposition temperature :No data available
Flammability (solid, gas) :Highly flammable liquid and vapor,Non flammable
Vapor pressure :No data available
Relative vapor density at 20 C :No data available
Relative density :<=
Specific gravity / density :1.5
Solubility :No data available
Log Pow :No data available
Viscosity, kinematic :No data available
Viscosity, dynamic :No data available
Explosive properties :No data available
Oxidizing properties :No data available
Explosion limits :No data available
9.2. Other information
No additional information available
AQUABUFF 1000W
Safety Data Sheet
according to Regulation (EC) No. 453/2010
18/02/2016 EN (English US) 4/6
SECTION 10: Stability and reactivity
10.1.Reactivity
No reactivity hazard other than the effects described in sub-sections below.
10.2.Chemical stability
Polymerization can result in formation of solid deposits, even in vapour space. Highly flammable liquid and vapor. Not established.
10.3.Possibility of hazardous reactions
Not established.
10.4.Conditions to avoid
Direct sunlight. Extremely high or low temperatures.
10.5.Incompatible materials
Strong acids. Strong bases.
10.6.Hazardous decomposition products
fume. Carbon monoxide. Carbon dioxide.
SECTION 11: Toxicological information
11.1.Information on toxicological effects
Acute toxicity :Not classified
Skin corrosion/irritation :Not classified
Serious eye damage/irritation :Not classified
Respiratory or skin sensitization :Not classified
Based on available data, the classification criteria are not met
Germ cell mutagenicity :Not classified
Carcinogenicity :Not classified
Reproductive toxicity :Not classified
Based on available data, the classification criteria are not met
Specific target organ toxicity (single exposure):Not classified
Based on available data, the classification criteria are not met
Specific target organ toxicity (repeated
exposure)
:Not classified
Based on available data, the classification criteria are not met
Aspiration hazard :Not classified
Based on available data, the classification criteria are not met
Potential Adverse human health effects and
symptoms
:Harmful if inhaled. Based on available data, the classification criteria are not met.
SECTION 12: Ecological information
12.1.Toxicity
No additional information available
12.2.Persistence and degradability
AQUABUFF 1000W(mixture)
Persistence and degradability Not established.
12.3.Bioaccumulative potential
AQUABUFF 1000W(mixture)
Bioaccumulative potential Not established.
12.4.Mobility in soil
No additional information available
12.5.Results of PBT and vPvB assessment
No additional information available
12.6.Other adverse effects
:Avoid release to the environment
AQUABUFF 1000W
Safety Data Sheet
according to Regulation (EC) No. 453/2010
18/02/2016 EN (English US) 5/6
SECTION 13: Disposal considerations
13.1.Waste treatment methods
Waste disposal recommendations :Dispose in a safe manner in accordance with local/national regulations.
Ecology - waste materials :Avoid release to the environment.
SECTION 14: Transport information
In accordance with ADR / RID / IMDG / IATA / ADN
14.1.UN number
UN-No. :NA
UN-No. (IATA) :NA
UN-No. (IMDG) :NA
UN-No. (ADN) :NA
14.2.UN proper shipping name
Proper Shipping Name :NOT REGULATED
Proper Shipping Name (IATA) :NOT REGULATED
Proper Shipping Name (IMDG) :NOT REGULATED
Proper Shipping Name (ADN) :NOT REGULATED
Transport document description :UN NA
14.3.Transport hazard class(es)
Not applicable
14.4.Packing group
Not applicable
14.5.Environmental hazards
Dangerous for the environment
Marine pollutant
:
:
No
No
Other information :No supplementary information available.
14.6.Special precautions for user
14.6.1.Overland transport
Hazard identification number (Kemler No.):30
Orange plates :
Transport category (ADR) :2
14.6.2.Transport by sea
No additional information available
14.6.3.Air transport
No additional information available
14.6.4.Inland waterway transport
No additional information available
14.7.Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code
Not applicable
SECTION 15: Regulatory information
15.1.Safety, health and environmental regulations/legislation specific for the substance or mixture
15.1.1.EU-Regulations
No REACH Annex XVII restrictions
Contains no REACH candidate substance
Seveso Information :
15.1.2.National regulations
No additional information available
AQUABUFF 1000W
Safety Data Sheet
according to Regulation (EC) No. 453/2010
18/02/2016 EN (English US) 6/6
15.2.Chemical safety assessment
No chemical safety assessment has been carried out
SECTION 16: Other information
Other information :None.
SDS EU (REACH Annex II)
Information herein is given in good faith as authoratative and valid. However no warranty expressed or implied can be made.
by | Sep 27, 2025
AQUA BUFF 1000W
LS51003
POLISHING COMPOUND
SAFETY DATA SHEET
Page 1 of 3
PRINTED: 2015-01-23
REVISED:09/23/2020 9/25/2020 11:17 AM
Page 1 of 3
Section 1 CHEMICAL PRODUCT and COMPANY IDENTIFICATION
Identification: Product Name:
Recommended use:
Manufacturer:
Emergency telephone:
AQUA BUFF 1000W (L S51003)
Polishing
Osborn
3440 Symmes Road
Hamilton, OH 45015
Telephone: 513-860-3400
ChemTrec (24hr) 800-424-9300
Section 2 HAZARDS IDENTIFICATION
Hazard Classification: Irritant
WARNING: Dust may temporarily irritate eyes, skin, and
respiratory system.
Hazard Symbols:
Hazard Classifications:
NFPA HAZARD RATING: Fire: (1, minimal) Health: (2, slight) Reactivity: (1, minimal)
GHS HAZARDS: Fire: (5, minimal) Health: (4, slight) Reactivity: (5, minimal)
National Fire Protection Association (NFPA) Ratings: This information is intended solely for the use of
individuals trained in the NFPA system.
Hazard phrases:
H316, H320, H335: Dust produced during use may cause mild irritation of skin, eyes, and respiratory
tract.
Precautionary Phrases:
P102: Keep out of reach of children.
P261: Avoid breathing dust, may cause respiratory tract irritation
P264: Wash thoroughly after handling. Avoid skin irritation by wearing protective gloves. If needed
wear eye protection and dust mask.
Emergency Overview: Dust generated in use may cause temporary irritation to skin, eyes, nose,
and respiratory tract. Exposure should be minimized.
Section 3 COMPOSITION / INFORMATION ON INGREDIENTS
CHEMICAL NAME CAS Number EC Number % Range
Aluminum oxide, non-fibrous 1344-28-1 215-691-6 40-50
Water 7732-18-5 231-791-2 40-50
Tallow derivatives Proprietary Proprietary 10-15
Section 4 FIRST AID MEASURES
General: Remove contaminated clothing.
Inhalation: If excessive dust is inhaled, remove to fresh air. Seek medical attention if breathing
difficulties persist.
Eye Contact: Check for and remove any contact lenses. Flush eyes with large amounts of water, cold
water may be used. Seek medical attention if vision difficulties occur.
Skin Contact: Wash contaminated skin with soapy water. Remove contaminated clothing and shoes. Wash
clothing and shoes before reuse.
Ingestion: Immediately rinse mouth and drink plenty of water. DO NOT INDUCE VOMITING unless
directed to do so by medical personnel. Never give anything by mouth to an unconscious person.
Ingestion of small quantities is not expected to produce symptoms. If large quantities are swallowed,
obtain medical help.
AQUA BUFF 1000W
LS51003
POLISHING COMPOUND
SAFETY DATA SHEET
Page 2 of 3
PRINTED: 2015-01-23
REVISED:09/23/2020 9/25/2020 11:17 AM
Page 2 of 3
Section 5 FIRE FIGHTING MEASURES
Flash Point & Method: over 370 F (estimated).
Fire Fighting Instructions: Water-based, not flammable in liquid state.
Fire Fighting Equipment: Use self-contained breathing apparatus and turn-out gear.
Hazards during fire-fighting: Heat may produce steam which can cause burns.
Section 6 ACCIDENTAL RELEASE MEASURES
Emergency Action: Isolate spill or leak area immediately.
May make floor slippery while wet. If material cannot be recovered, transfer to waste container for
disposal in local landfill, complying with local, state and federal regulations. Clean up residues with water.
Section 7 HANDLING AND STORAGE
Handling: Wear protective gloves if skin irritation is experienced. Wash hands before eating. Avoid
breathing dust produced in use.
Storage: Store at room temperature. Avoid freezing and excessive heat.
Section 8 EXPOSURE CONTROL / PERSONAL PROTECTION
CAS Number EC Number OSHA PEL ACGIH TLV
Aluminum oxide, non-
fibrous
1344-28-1 215-691-6 15 mg/m 3 TWA 10 mg/m 3 TWA
Engineering Controls: Provide exhaust ventilation or other engineering controls to keep dust levels below
occupational exposure limits. See section 2 for component exposure guidelines. Local
exhaust ventilation is acceptable.
Respirator: Use a NIOSH-certified dust mask or equivalent.
Hand Protection: Wear gloves.
Eye Protection: Protective eye-wear should be used in dusty environment.
Other Recommendations: Wear protective clothing such as long sleeves. Wash hands after handling.
Section 9 PHYSICAL AND CHEMICAL PROPERTIES
Density approximately 1.5 g/cm3 (25 C / 77 F)
pH 9.5 10.5 Physical State Liquid, thick cream
Boiling Point approximately 212 F / 100 C Solubility in water Dispersible
Freeze Point approximately 32 F / 0 C Appearance Blue creamy paste
Vapor Density (Air=1) No data available Odor Mildly chemical
Section 10 STABILITY AND REACTIVITY
General: Stable
Incompatible Materials and Conditions to Avoid: Strong oxidizing agents
Hazardous Polymerization: Will not occur.
Section 11 TOXICOLOGY INFORMATION
No information available on Acute or Chronic ingestion or inhalation toxicity.
No ingredients present above 0.1% which are carcinogenic according to NTP, IARC, or OSHA findings.
Section 12 ECOLOGICAL INFORMATION
All ingredients are inert in the environment, or biodegrade to non-hazardous compounds.
Section 13 DISPOSAL CONSIDERATIONS
RCRA 40 CFR 261 Classifications: not classified as hazardous.
Federal, State, and Local laws governing disposal of material can differ. May be disposed in local
landfill in compliance with proper authorities.
AQUA BUFF 1000W
LS51003
POLISHING COMPOUND
SAFETY DATA SHEET
Page 3 of 3
PRINTED: 2015-01-23
REVISED:09/23/2020 9/25/2020 11:17 AM
Page 3 of 3
Section 14 TRANSPORTATION INFORMATION
NON-HAZARDOUS MATERIAL Not regulated for transportation under US DOT, IATA, ICAO, IMDG, Canadian
TDG Regulations, or EU ADR.
Section 15 REGULATORY INFORMATION
US Federal Regulations: SDS complies with the OSHA Hazard Communication Rule, 29 CFR 1910.1200.
CERCLA/Superfund, 40 CFR 117, 302: None of the chemicals are CERCLA hazards
SARA Superfund and Reauthorization Act of 1986 Title III sections 302, 311, 312 and 313:
Section 302 None of the chemicals are extremely hazardous substances (40 CFR 355).
Section 311/312 Material Safety Data Sheet Requirements (40 CFR 370): By our hazard evaluation,
this product may be an eye and skin irritant.
Section 313 List of Toxic Chemicals (40CFC 372): This product contains no chemicals (at level of 1%
or greater) that are found on the 313 list of Toxic Chemicals.
Toxic Substance Control Act (TSCA): All substances are TSCA listed.
Resource Conservation and Recovery Act (RCRA 40 CFR 261) Subpart C & D: Refer to Section 13.
STATE REGULATIONS:
No substances in this mixture are specifically listed by individual state. Other product specific health
and safety data in other sections of the SDS may also be applicable for state requirements. For
details on your regulatory requirements you should contact the appropriate agency in your state.
California Proposition 65: None of the ingredients are on the Proposition 65 list
Canada WHMIS: Not Controlled. All components of this product are included in the Canadian DSL
(Domestic Substances List)
Sections 16 OTHER INFORMATION
LABEL INFORMATION: For Shipping Label information refer to section 14
Product label warnings are as follows (Comparable CHIP Safety & Risk phrases are noted):
[H303] May be harmful if swallowed.
[P102] Keep out of the reach of children. [P271] Use outdoors or in ventilated area.
[P280] Wear protective gloves and eye protection, to avoid skin and eye irritation.
REVISION DATES SECTIONS REVISED BY
9/25/2020 Company info eb
ABBREVIATIONS USED IN THIS DOCUMENT: NE Not Established, NA Not Applicable, NIF No Information Found
ABRIDGED LIST OF REFERENCES:
Code of Federal Regulations (CFR)
Chemical Guide and OSHA Hazardous Communication Standard
US Department of Labor; Occupational Safety & Health Administration (www.osha.gov)
The Environmental Protection Agency (www.epa.gov)
The Globally Harmonized System of Classification and Labeling of Chemicals (GHS)
Government of Canada: http://canadagazette.gc.ca/news-e.html
To the best of our knowledge, the information contained herein is accurate. However, neither Osborn nor any of its subsidiaries assumes
any liability whatsoever for the accuracy or completeness of the information contained herein. Final determination of suitability of any
material is the sole responsibility of the user. All materials may present unknown hazards and should be used with caution. Although
certain hazards are described herein, we cannot guarantee that these are the only hazards which exist.
by | Sep 27, 2025
AQUA BUFF 1000W
LS51003
POLISHING COMPOUND
SAFETY DATA SHEET
Page 1 of 3
PRINTED: 2015-01-23
REVISED:09/23/2020 9/25/2020 11:17 AM
Page 1 of 3
Section 1 CHEMICAL PRODUCT and COMPANY IDENTIFICATION
Identification: Product Name:
Recommended use:
Manufacturer:
Emergency telephone:
AQUA BUFF 1000W (L S51003)
Polishing
Osborn
3440 Symmes Road
Hamilton, OH 45015
Telephone: 513-860-3400
ChemTrec (24hr) 800-424-9300
Section 2 HAZARDS IDENTIFICATION
Hazard Classification: Irritant
WARNING: Dust may temporarily irritate eyes, skin, and
respiratory system.
Hazard Symbols:
Hazard Classifications:
NFPA HAZARD RATING: Fire: (1, minimal) Health: (2, slight) Reactivity: (1, minimal)
GHS HAZARDS: Fire: (5, minimal) Health: (4, slight) Reactivity: (5, minimal)
National Fire Protection Association (NFPA) Ratings: This information is intended solely for the use of
individuals trained in the NFPA system.
Hazard phrases:
H316, H320, H335: Dust produced during use may cause mild irritation of skin, eyes, and respiratory
tract.
Precautionary Phrases:
P102: Keep out of reach of children.
P261: Avoid breathing dust, may cause respiratory tract irritation
P264: Wash thoroughly after handling. Avoid skin irritation by wearing protective gloves. If needed
wear eye protection and dust mask.
Emergency Overview: Dust generated in use may cause temporary irritation to skin, eyes, nose,
and respiratory tract. Exposure should be minimized.
Section 3 COMPOSITION / INFORMATION ON INGREDIENTS
CHEMICAL NAME CAS Number EC Number % Range
Aluminum oxide, non-fibrous 1344-28-1 215-691-6 40-50
Water 7732-18-5 231-791-2 40-50
Tallow derivatives Proprietary Proprietary 10-15
Section 4 FIRST AID MEASURES
General: Remove contaminated clothing.
Inhalation: If excessive dust is inhaled, remove to fresh air. Seek medical attention if breathing
difficulties persist.
Eye Contact: Check for and remove any contact lenses. Flush eyes with large amounts of water, cold
water may be used. Seek medical attention if vision difficulties occur.
Skin Contact: Wash contaminated skin with soapy water. Remove contaminated clothing and shoes. Wash
clothing and shoes before reuse.
Ingestion: Immediately rinse mouth and drink plenty of water. DO NOT INDUCE VOMITING unless
directed to do so by medical personnel. Never give anything by mouth to an unconscious person.
Ingestion of small quantities is not expected to produce symptoms. If large quantities are swallowed,
obtain medical help.
AQUA BUFF 1000W
LS51003
POLISHING COMPOUND
SAFETY DATA SHEET
Page 2 of 3
PRINTED: 2015-01-23
REVISED:09/23/2020 9/25/2020 11:17 AM
Page 2 of 3
Section 5 FIRE FIGHTING MEASURES
Flash Point & Method: over 370 F (estimated).
Fire Fighting Instructions: Water-based, not flammable in liquid state.
Fire Fighting Equipment: Use self-contained breathing apparatus and turn-out gear.
Hazards during fire-fighting: Heat may produce steam which can cause burns.
Section 6 ACCIDENTAL RELEASE MEASURES
Emergency Action: Isolate spill or leak area immediately.
May make floor slippery while wet. If material cannot be recovered, transfer to waste container for
disposal in local landfill, complying with local, state and federal regulations. Clean up residues with water.
Section 7 HANDLING AND STORAGE
Handling: Wear protective gloves if skin irritation is experienced. Wash hands before eating. Avoid
breathing dust produced in use.
Storage: Store at room temperature. Avoid freezing and excessive heat.
Section 8 EXPOSURE CONTROL / PERSONAL PROTECTION
CAS Number EC Number OSHA PEL ACGIH TLV
Aluminum oxide, non-
fibrous
1344-28-1 215-691-6 15 mg/m 3 TWA 10 mg/m 3 TWA
Engineering Controls: Provide exhaust ventilation or other engineering controls to keep dust levels below
occupational exposure limits. See section 2 for component exposure guidelines. Local
exhaust ventilation is acceptable.
Respirator: Use a NIOSH-certified dust mask or equivalent.
Hand Protection: Wear gloves.
Eye Protection: Protective eye-wear should be used in dusty environment.
Other Recommendations: Wear protective clothing such as long sleeves. Wash hands after handling.
Section 9 PHYSICAL AND CHEMICAL PROPERTIES
Density approximately 1.5 g/cm3 (25 C / 77 F)
pH 9.5 10.5 Physical State Liquid, thick cream
Boiling Point approximately 212 F / 100 C Solubility in water Dispersible
Freeze Point approximately 32 F / 0 C Appearance Blue creamy paste
Vapor Density (Air=1) No data available Odor Mildly chemical
Section 10 STABILITY AND REACTIVITY
General: Stable
Incompatible Materials and Conditions to Avoid: Strong oxidizing agents
Hazardous Polymerization: Will not occur.
Section 11 TOXICOLOGY INFORMATION
No information available on Acute or Chronic ingestion or inhalation toxicity.
No ingredients present above 0.1% which are carcinogenic according to NTP, IARC, or OSHA findings.
Section 12 ECOLOGICAL INFORMATION
All ingredients are inert in the environment, or biodegrade to non-hazardous compounds.
Section 13 DISPOSAL CONSIDERATIONS
RCRA 40 CFR 261 Classifications: not classified as hazardous.
Federal, State, and Local laws governing disposal of material can differ. May be disposed in local
landfill in compliance with proper authorities.
AQUA BUFF 1000W
LS51003
POLISHING COMPOUND
SAFETY DATA SHEET
Page 3 of 3
PRINTED: 2015-01-23
REVISED:09/23/2020 9/25/2020 11:17 AM
Page 3 of 3
Section 14 TRANSPORTATION INFORMATION
NON-HAZARDOUS MATERIAL Not regulated for transportation under US DOT, IATA, ICAO, IMDG, Canadian
TDG Regulations, or EU ADR.
Section 15 REGULATORY INFORMATION
US Federal Regulations: SDS complies with the OSHA Hazard Communication Rule, 29 CFR 1910.1200.
CERCLA/Superfund, 40 CFR 117, 302: None of the chemicals are CERCLA hazards
SARA Superfund and Reauthorization Act of 1986 Title III sections 302, 311, 312 and 313:
Section 302 None of the chemicals are extremely hazardous substances (40 CFR 355).
Section 311/312 Material Safety Data Sheet Requirements (40 CFR 370): By our hazard evaluation,
this product may be an eye and skin irritant.
Section 313 List of Toxic Chemicals (40CFC 372): This product contains no chemicals (at level of 1%
or greater) that are found on the 313 list of Toxic Chemicals.
Toxic Substance Control Act (TSCA): All substances are TSCA listed.
Resource Conservation and Recovery Act (RCRA 40 CFR 261) Subpart C & D: Refer to Section 13.
STATE REGULATIONS:
No substances in this mixture are specifically listed by individual state. Other product specific health
and safety data in other sections of the SDS may also be applicable for state requirements. For
details on your regulatory requirements you should contact the appropriate agency in your state.
California Proposition 65: None of the ingredients are on the Proposition 65 list
Canada WHMIS: Not Controlled. All components of this product are included in the Canadian DSL
(Domestic Substances List)
Sections 16 OTHER INFORMATION
LABEL INFORMATION: For Shipping Label information refer to section 14
Product label warnings are as follows (Comparable CHIP Safety & Risk phrases are noted):
[H303] May be harmful if swallowed.
[P102] Keep out of the reach of children. [P271] Use outdoors or in ventilated area.
[P280] Wear protective gloves and eye protection, to avoid skin and eye irritation.
REVISION DATES SECTIONS REVISED BY
9/25/2020 Company info eb
ABBREVIATIONS USED IN THIS DOCUMENT: NE Not Established, NA Not Applicable, NIF No Information Found
ABRIDGED LIST OF REFERENCES:
Code of Federal Regulations (CFR)
Chemical Guide and OSHA Hazardous Communication Standard
US Department of Labor; Occupational Safety & Health Administration (www.osha.gov)
The Environmental Protection Agency (www.epa.gov)
The Globally Harmonized System of Classification and Labeling of Chemicals (GHS)
Government of Canada: http://canadagazette.gc.ca/news-e.html
To the best of our knowledge, the information contained herein is accurate. However, neither Osborn nor any of its subsidiaries assumes
any liability whatsoever for the accuracy or completeness of the information contained herein. Final determination of suitability of any
material is the sole responsibility of the user. All materials may present unknown hazards and should be used with caution. Although
certain hazards are described herein, we cannot guarantee that these are the only hazards which exist.
by | Sep 27, 2025
AQUA BUFF 1000W
LS51003
POLISHING COMPOUND
SAFETY DATA SHEET
Page 1 of 3
PRINTED: 2015-01-23
REVISED:09/23/2020 9/25/2020 11:17 AM
Page 1 of 3
Section 1 CHEMICAL PRODUCT and COMPANY IDENTIFICATION
Identification: Product Name:
Recommended use:
Manufacturer:
Emergency telephone:
AQUA BUFF 1000W (L S51003)
Polishing
Osborn
3440 Symmes Road
Hamilton, OH 45015
Telephone: 513-860-3400
ChemTrec (24hr) 800-424-9300
Section 2 HAZARDS IDENTIFICATION
Hazard Classification: Irritant
WARNING: Dust may temporarily irritate eyes, skin, and
respiratory system.
Hazard Symbols:
Hazard Classifications:
NFPA HAZARD RATING: Fire: (1, minimal) Health: (2, slight) Reactivity: (1, minimal)
GHS HAZARDS: Fire: (5, minimal) Health: (4, slight) Reactivity: (5, minimal)
National Fire Protection Association (NFPA) Ratings: This information is intended solely for the use of
individuals trained in the NFPA system.
Hazard phrases:
H316, H320, H335: Dust produced during use may cause mild irritation of skin, eyes, and respiratory
tract.
Precautionary Phrases:
P102: Keep out of reach of children.
P261: Avoid breathing dust, may cause respiratory tract irritation
P264: Wash thoroughly after handling. Avoid skin irritation by wearing protective gloves. If needed
wear eye protection and dust mask.
Emergency Overview: Dust generated in use may cause temporary irritation to skin, eyes, nose,
and respiratory tract. Exposure should be minimized.
Section 3 COMPOSITION / INFORMATION ON INGREDIENTS
CHEMICAL NAME CAS Number EC Number % Range
Aluminum oxide, non-fibrous 1344-28-1 215-691-6 40-50
Water 7732-18-5 231-791-2 40-50
Tallow derivatives Proprietary Proprietary 10-15
Section 4 FIRST AID MEASURES
General: Remove contaminated clothing.
Inhalation: If excessive dust is inhaled, remove to fresh air. Seek medical attention if breathing
difficulties persist.
Eye Contact: Check for and remove any contact lenses. Flush eyes with large amounts of water, cold
water may be used. Seek medical attention if vision difficulties occur.
Skin Contact: Wash contaminated skin with soapy water. Remove contaminated clothing and shoes. Wash
clothing and shoes before reuse.
Ingestion: Immediately rinse mouth and drink plenty of water. DO NOT INDUCE VOMITING unless
directed to do so by medical personnel. Never give anything by mouth to an unconscious person.
Ingestion of small quantities is not expected to produce symptoms. If large quantities are swallowed,
obtain medical help.
AQUA BUFF 1000W
LS51003
POLISHING COMPOUND
SAFETY DATA SHEET
Page 2 of 3
PRINTED: 2015-01-23
REVISED:09/23/2020 9/25/2020 11:17 AM
Page 2 of 3
Section 5 FIRE FIGHTING MEASURES
Flash Point & Method: over 370 F (estimated).
Fire Fighting Instructions: Water-based, not flammable in liquid state.
Fire Fighting Equipment: Use self-contained breathing apparatus and turn-out gear.
Hazards during fire-fighting: Heat may produce steam which can cause burns.
Section 6 ACCIDENTAL RELEASE MEASURES
Emergency Action: Isolate spill or leak area immediately.
May make floor slippery while wet. If material cannot be recovered, transfer to waste container for
disposal in local landfill, complying with local, state and federal regulations. Clean up residues with water.
Section 7 HANDLING AND STORAGE
Handling: Wear protective gloves if skin irritation is experienced. Wash hands before eating. Avoid
breathing dust produced in use.
Storage: Store at room temperature. Avoid freezing and excessive heat.
Section 8 EXPOSURE CONTROL / PERSONAL PROTECTION
CAS Number EC Number OSHA PEL ACGIH TLV
Aluminum oxide, non-
fibrous
1344-28-1 215-691-6 15 mg/m 3 TWA 10 mg/m 3 TWA
Engineering Controls: Provide exhaust ventilation or other engineering controls to keep dust levels below
occupational exposure limits. See section 2 for component exposure guidelines. Local
exhaust ventilation is acceptable.
Respirator: Use a NIOSH-certified dust mask or equivalent.
Hand Protection: Wear gloves.
Eye Protection: Protective eye-wear should be used in dusty environment.
Other Recommendations: Wear protective clothing such as long sleeves. Wash hands after handling.
Section 9 PHYSICAL AND CHEMICAL PROPERTIES
Density approximately 1.5 g/cm3 (25 C / 77 F)
pH 9.5 10.5 Physical State Liquid, thick cream
Boiling Point approximately 212 F / 100 C Solubility in water Dispersible
Freeze Point approximately 32 F / 0 C Appearance Blue creamy paste
Vapor Density (Air=1) No data available Odor Mildly chemical
Section 10 STABILITY AND REACTIVITY
General: Stable
Incompatible Materials and Conditions to Avoid: Strong oxidizing agents
Hazardous Polymerization: Will not occur.
Section 11 TOXICOLOGY INFORMATION
No information available on Acute or Chronic ingestion or inhalation toxicity.
No ingredients present above 0.1% which are carcinogenic according to NTP, IARC, or OSHA findings.
Section 12 ECOLOGICAL INFORMATION
All ingredients are inert in the environment, or biodegrade to non-hazardous compounds.
Section 13 DISPOSAL CONSIDERATIONS
RCRA 40 CFR 261 Classifications: not classified as hazardous.
Federal, State, and Local laws governing disposal of material can differ. May be disposed in local
landfill in compliance with proper authorities.
AQUA BUFF 1000W
LS51003
POLISHING COMPOUND
SAFETY DATA SHEET
Page 3 of 3
PRINTED: 2015-01-23
REVISED:09/23/2020 9/25/2020 11:17 AM
Page 3 of 3
Section 14 TRANSPORTATION INFORMATION
NON-HAZARDOUS MATERIAL Not regulated for transportation under US DOT, IATA, ICAO, IMDG, Canadian
TDG Regulations, or EU ADR.
Section 15 REGULATORY INFORMATION
US Federal Regulations: SDS complies with the OSHA Hazard Communication Rule, 29 CFR 1910.1200.
CERCLA/Superfund, 40 CFR 117, 302: None of the chemicals are CERCLA hazards
SARA Superfund and Reauthorization Act of 1986 Title III sections 302, 311, 312 and 313:
Section 302 None of the chemicals are extremely hazardous substances (40 CFR 355).
Section 311/312 Material Safety Data Sheet Requirements (40 CFR 370): By our hazard evaluation,
this product may be an eye and skin irritant.
Section 313 List of Toxic Chemicals (40CFC 372): This product contains no chemicals (at level of 1%
or greater) that are found on the 313 list of Toxic Chemicals.
Toxic Substance Control Act (TSCA): All substances are TSCA listed.
Resource Conservation and Recovery Act (RCRA 40 CFR 261) Subpart C & D: Refer to Section 13.
STATE REGULATIONS:
No substances in this mixture are specifically listed by individual state. Other product specific health
and safety data in other sections of the SDS may also be applicable for state requirements. For
details on your regulatory requirements you should contact the appropriate agency in your state.
California Proposition 65: None of the ingredients are on the Proposition 65 list
Canada WHMIS: Not Controlled. All components of this product are included in the Canadian DSL
(Domestic Substances List)
Sections 16 OTHER INFORMATION
LABEL INFORMATION: For Shipping Label information refer to section 14
Product label warnings are as follows (Comparable CHIP Safety & Risk phrases are noted):
[H303] May be harmful if swallowed.
[P102] Keep out of the reach of children. [P271] Use outdoors or in ventilated area.
[P280] Wear protective gloves and eye protection, to avoid skin and eye irritation.
REVISION DATES SECTIONS REVISED BY
9/25/2020 Company info eb
ABBREVIATIONS USED IN THIS DOCUMENT: NE Not Established, NA Not Applicable, NIF No Information Found
ABRIDGED LIST OF REFERENCES:
Code of Federal Regulations (CFR)
Chemical Guide and OSHA Hazardous Communication Standard
US Department of Labor; Occupational Safety & Health Administration (www.osha.gov)
The Environmental Protection Agency (www.epa.gov)
The Globally Harmonized System of Classification and Labeling of Chemicals (GHS)
Government of Canada: http://canadagazette.gc.ca/news-e.html
To the best of our knowledge, the information contained herein is accurate. However, neither Osborn nor any of its subsidiaries assumes
any liability whatsoever for the accuracy or completeness of the information contained herein. Final determination of suitability of any
material is the sole responsibility of the user. All materials may present unknown hazards and should be used with caution. Although
certain hazards are described herein, we cannot guarantee that these are the only hazards which exist.
by | Sep 27, 2025
AQUA BUFF 1000F
LS51103
POLISHING COMPOUND
SAFETY DATA SHEET
Page 1 of 3
PRINTED: 2015-01-23
REVISED: 09/23/2020
Page 1 of 3
Section 1 CHEMICAL PRODUCT and COMPANY IDENTIFICATION
Identification: Product Name:
Recommended use:
Manufacturer:
Emergency telephone:
AQUA BUFF 1000F ( LS51103)
Polishing
Osborn
3440 Symmes Road
Hamilton, OH 45015
Telephone: 513-860-3400
ChemTrec (24hr) 800-424-9300
Section 2 HAZARDS IDENTIFICATION
Hazard Classification: Irritant
WARNING: Dust may temporarily irritate eyes, skin, and
respiratory system.
Hazard Symbols:
Hazard Classifications:
NFPA HAZARD RATING: Fire: (1, minimal) Health: (2, slight) Reactivity: (1, minimal)
GHS HAZARDS: Fire: (5, minimal) Health: (4, slight) Reactivity: (5, minimal)
National Fire Protection Association (NFPA) Ratings: This information is intended solely for the use of
individuals trained in the NFPA system.
Hazard phrases:
H316, H320, H335: Dust produced during use may cause mild irritation of skin, eyes, and respiratory
tract.
Precautionary Phrases:
P102: Keep out of reach of children.
P261: Avoid breathing dust, may cause respiratory tract irritation
P264: Wash thoroughly after handling. Avoid skin irritation by wearing protective gloves. If needed
wear eye protection and dust mask.
Emergency Overview: Dust generated in use may cause temporary irritation to skin, eyes, nose,
and respiratory tract. Exposure should be minimized.
Section 3 COMPOSITION / INFORMATION ON INGREDIENTS
CHEMICAL NAME CAS Number EC Number % Range
Aluminum oxide, non-fibrous 1344-28-1 215-691-6 40-50
Water 7732-18-5 231-791-2 40-50
Tallow derivatives Proprietary Proprietary 10-15
Section 4 FIRST AID MEASURES
General: Remove contaminated clothing.
Inhalation: If excessive dust is inhaled, remove to fresh air. Seek medical attention if breathing
difficulties persist.
Eye Contact: Check for and remove any contact lenses. Flush eyes with large amounts of water, cold
water may be used. Seek medical attention if vision difficulties occur.
Skin Contact: Wash contaminated skin with soapy water. Remove contaminated clothing and shoes. Wash
clothing and shoes before reuse.
Ingestion: Immediately rinse mouth and drink plenty of water. DO NOT INDUCE VOMITING unless
directed to do so by medical personnel. Never give anything by mouth to an unconscious person.
Ingestion of small quantities is not expected to produce symptoms. If large quantities are swallowed,
obtain medical help.
AQUA BUFF 1000F
LS51103
POLISHING COMPOUND
SAFETY DATA SHEET
Page 2 of 3
PRINTED: 2015-01-23
REVISED: 09/23/2020
Page 2 of 3
Section 5 FIRE FIGHTING MEASURES
Flash Point & Method: over 370 F (estimated).
Fire Fighting Instructions: Water-based, not flammable in liquid state.
Fire Fighting Equipment: Use self-contained breathing apparatus and turn-out gear.
Hazards during fire-fighting: Heat may produce steam which can cause burns.
Section 6 ACCIDENTAL RELEASE MEASURES
Emergency Action: Isolate spill or leak area immediately.
May make floor slippery while wet. If material cannot be recovered, transfer to waste container for
disposal in local landfill, complying with local, state and federal regulations. Clean up residues with water.
Section 7 HANDLING AND STORAGE
Handling: Wear protective gloves if skin irritation is experienced. Wash hands before eating. Avoid
breathing dust produced in use.
Storage: Store at room temperature. Avoid freezing and excessive heat.
Section 8 EXPOSURE CONTROL / PERSONAL PROTECTION
CAS Number EC Number OSHA PEL ACGIH TLV
Aluminum oxide, non-
fibrous
1344-28-1 215-691-6 15 mg/m 3 TWA 10 mg/m 3 TWA
Engineering Controls: Provide exhaust ventilation or other engineering controls to keep dust levels below
occupational exposure limits. See section 2 for component exposure guidelines. Local
exhaust ventilation is acceptable.
Respirator: Use a NIOSH-certified dust mask or equivalent.
Hand Protection: Wear gloves.
Eye Protection: Protective eye-wear should be used in dusty environment.
Other Recommendations: Wear protective clothing such as long sleeves. Wash hands after handling.
Section 9 PHYSICAL AND CHEMICAL PROPERTIES
Density approximately 1.5 g/cm3 (25 C / 77 F)
pH 9.5 10.5 Physical State Liquid, thick cream
Boiling Point approximately 212 F / 100 C Solubility in water Dispersible
Freeze Point approximately 32 F / 0 C Appearance Grey creamy paste
Vapor Density (Air=1) No data available Odor Mildly chemical
Section 10 STABILITY AND REACTIVITY
General: Stable
Incompatible Materials and Conditions to Avoid: Strong oxidizing agents
Hazardous Polymerization: Will not occur.
Section 11 TOXICOLOGY INFORMATION
No information available on Acute or Chronic ingestion or inhalation toxicity.
No ingredients present above 0.1% which are carcinogenic according to NTP, IARC, or OSHA findings.
Section 12 ECOLOGICAL INFORMATION
All ingredients are inert in the environment, or biodegrade to non-hazardous compounds.
Section 13 DISPOSAL CONSIDERATIONS
RCRA 40 CFR 261 Classifications: not classified as hazardous.
AQUA BUFF 1000F
LS51103
POLISHING COMPOUND
SAFETY DATA SHEET
Page 3 of 3
PRINTED: 2015-01-23
REVISED: 09/23/2020
Page 3 of 3
Federal, State, and Local laws governing disposal of material can differ. May be disposed in local
landfill in compliance with proper authorities.
Section 14 TRANSPORTATION INFORMATION
NON-HAZARDOUS MATERIAL: Not regulated for transportation under US DOT, IATA, ICAO, IMDG, Canadian
TDG Regulations, or EU ADR.
Section 15 REGULATORY INFORMATION
US Federal Regulations: SDS complies with the OSHA Hazard Communication Rule, 29 CFR 1910.1200.
CERCLA/Superfund, 40 CFR 117, 302: None of the chemicals are CERCLA hazards
SARA Superfund and Reauthorization Act of 1986 Title III sections 302, 311, 312 and 313:
Section 302 None of the chemicals are extremely hazardous substances (40 CFR 355).
Section 311/312 Material Safety Data Sheet Requirements (40 CFR 370): By our hazard evaluation,
this product may be an eye and skin irritant.
Section 313 List of Toxic Chemicals (40CFC 372): This product contains no chemicals (at level of 1%
or greater) that are found on the 313 list of Toxic Chemicals.
Toxic Substance Control Act (TSCA): All substances are TSCA listed.
Resource Conservation and Recovery Act (RCRA 40 CFR 261) Subpart C & D: Refer to Section 13.
STATE REGULATIONS:
No substances in this mixture are specifically listed by individual state. Other product specific health
and safety data in other sections of the SDS may also be applicable for state requirements. For
details on your regulatory requirements you should contact the appropriate agency in your state.
California Proposition 65: None of the ingredients are on the Proposition 65 list
Canada WHMIS: Not Controlled. All components of this product are included in the Canadian DSL
(Domestic Substances List)
Sections 16 OTHER INFORMATION
LABEL INFORMATION: For Shipping Label information refer to section 14
Product label warnings are as follows (Comparable CHIP Safety & Risk phrases are noted):
[H303] May be harmful if swallowed.
[P102] Keep out of the reach of children. [P271] Use outdoors or in ventilated area.
[P280] Wear protective gloves and eye protection, to avoid skin and eye irritation.
REVISION DATES SECTIONS REVISED BY
9/25/2020 Company info eb
ABBREVIATIONS USED IN THIS DOCUMENT: NE Not Established, NA Not Applicable, NIF No Information Found
ABRIDGED LIST OF REFERENCES:
Code of Federal Regulations (CFR)
Chemical Guide and OSHA Hazardous Communication Standard
US Department of Labor; Occupational Safety & Health Administration (www.osha.gov)
The Environmental Protection Agency (www.epa.gov)
The Globally Harmonized System of Classification and Labeling of Chemicals (GHS)
Government of Canada: http://canadagazette.gc.ca/news-e.html
To the best of our knowledge, the information contained herein is accurate. However, neither Osborn nor any of its subsidiaries assumes
any liability whatsoever for the accuracy or completeness of the information contained herein. Final determination of suitability of any
material is the sole responsibility of the user. All materials may present unknown hazards and should be used with caution. Although
certain hazards are described herein, we cannot guarantee that these are the only hazards which exist.
