Stoner Incorporated ME-301S/S553 PAGE 1
Safety Data Sheet
ME-301S/S553 Pattern Release Mold Release
Copying and/or downloading of this information for the purpose of properly utilizing Stoner Inc. product is allowed provided that: (1) the
information is copied in full with no changes unless prior agreement is obtained from Stoner Inc., & (2) neither the copy nor the original is
resold or otherwise distributed with intention of earning profit thereon.
1. IDENTIFICATION
Stoner Incorporated Product Name: Pattern Release Mold Release
1070 Robert Fulton Hwy. Product Code: ME-301S/S553
Quarryville, PA 17566 Product Use: Mold Release
1-800-227-5538 24-hour emergency phone: 1-800-424-9300 [CHEMTREC]
2. HAZARD IDENTIFICATION
POTENTIAL HEALTH EFFECTS
Classification of the chemical in accordance with paragraph (d) of 1910.1200;
GHS Hazard Symbols
GHS Classification Gases under pressure – Liquified Gas
Flammable Aerosol Category 2
Signal Word Warning
Hazard Statements Flammable aerosol.
Contains gas under pressure; may explode if heated.
Precautionary Statements
Prevention Keep away from heat/sparks/open flames/hot surfaces. No smoking.
Do not spray on an open flame or other ignition source.
Pressurized container: Do not pierce or burn, even after use.
Storage Protect from sunlight. Store in a well-ventilated place.
Protect from sunlight. Do no expose to temperatures exceeding 50 C/ 122 F.
3. COMPOSITION/INFORMATION ON INGREDIENTS
COMPONENT CAS # Percent
Halogenated hydrocarbon/ether blend Mixture 1-20
Petroleum distillates 64741-65-7 1-20
HMIS III* HAZARDOUS WARNINGS:
Health:1 Flammability:3 Physical:2 Personal
Protective
Equipment:
See Section 8
* See www.paint.org/hmis or call the ACA at 1 (202) 462-6272 for more information on this current rating system.
4. FIRST AID MEASURES
Eyes: Immediately flush eyes gently with plenty of water for at least 15 minutes while holding eyelids apart. If symptoms persist or there
is visual difficulty, seek medical attention.
Skin Contact: In case of contact, immediately wash contaminated area with plenty of water for at least 15 minutes. For liquid contact, treat for
frostbite if necessary. Seek medical attention if symptoms persist. Wash clothing before reuse.
Ingestion: Do not induce vomiting. Contact a physician, medical facility, or poison control center immediately.
Inhalation: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Seek immediate medical
attention.
Stoner Incorporated ME-301S/S553 PAGE 2
NOTES TO PHYSICIAN:
Because of possible disturbances of cardiac rhythm, catecholamine drugs, such as epinephrine, should be used only in situations of emergency life
support. Preexisting disorders of the following organs (or organ systems) may be aggravated by exposure to this material: skin; lung (for example,
asthma-like conditions);
5. FIRE FIGHTING MEASURES
Fire and/or Explosion Hazards: This product contains a component(s) that is considered an extremely flammable gas(es), which has vapors that
are heavier than air and may travel along the ground or be moved by ventilation and ignited by heat, pilot lights,
or other flames and ignition sources at locations distant from the material’s handling point.Containers may rupture
or explode under fire conditions. In extreme fire conditions this material may present a floating fire hazard.
Fire Fighting Instructions: Use CO2, foam or dry chemical. Water is generally not effective and may spread fire; however, water spray may
be used from a safe distance to cool closed containers and protect surrounding area. Do not direct a solid stream of
water or foam into hot burning pools, this may cause frothing and increase fire intensity.
6. ACCIDENTAL RELEASE MEASURES
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
Ventilate contaminated area. Remove all sources of ignition. Wear appropriate personal protective equipment (PPE). Stop or reduce discharge if it can be
done safely. Clean up with absorbent material. Place absorbent materials into container and close it tightly. Dispose of container properly. Avoid run-off
into storm sewers and ditches which may lead to natural waterways. If runoff occurs, notify authorities as required.
7. HANDLING AND STORAGE
Handling: Use with adequate ventilation. Do not use near ignition sources. Avoid prolonged or repeated breathing of vapor. Avoid prolonged or
repeated contact with skin. May cause frostbite. Do not pressurize, cut, weld, braze, solder, drill, grind, or expose such containers to heat,
flame, sparks, static electricity, or other sources of ignition; they may explode and cause injury or death.
Storage: Store in a cool, dry, well ventilated area away from all sources of ignition. Do not store at temperatures above 122 degrees F. Store away
from oxygen cylinders or other oxidizing materials and possible ignition sources. Ground all equipment and cylinders before use. Empty
container may contain residues which are hazardous. Store away from incompatible materials such as materials that support combustion
(oxidizing materials) and corrosive materials (strong acids or bases).
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Engineering Controls: Ventilation should be adequate to prevent exposures above the limits indicated below in this section of the SDS (from
known, suspected or apparent adverse effects).
Eye Protection: Wear chemically resistant safety glasses with side shields when handling this product. Wear additional eye protection such as
chemical splash goggles and/or face shield when the possibility exists for eye contact with splashing or spraying liquid or
airborne material. Have an eye wash station available.
Skin Protection: The use of chemically resistant gloves is recommended if there is any possibility of prolonged or repeated liquid contact with
skin.
Respiratory Protection: A supplied air respirator should be used if ventilation is not sufficient to maintain exposure limits. Use NIOSH approved
respirator where there is likelihood of inhalation of the product mist, spray or aerosol.
COMPONENT CAS # ACGIH TLV OSHA PEL OTHER
Halogenated hydrocarbon/ether blend Mixture Not established Not established 1000ppm TWA (Mfr.)
Petroleum distillates 64741-65-7 100 ppm TWA 500 ppm Not established
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Aerosol can Lower Flammability Limit (%): Not applicable
Appearance: Hazy White to off-white Upper Flammability Limit (%): Not applicable
Odor: Slight ethereal. Vapor Pressure (PSIG @ 70 F):76.00
Odor Threshold: Mild Vapor Density [air = 1]: > 1
pH: Not applicable Relative Density (H2O=1): 0.74
Melting/Freezing Point ( F): No data available Solubility in Water: Not determined
Boiling Point ( F): No data available Partial Coefficient: n-
octanol/water:
No data available
Flash Point ( F PMCC): Not applicable Autoignition Temperature ( F):Not applicable
Evaporation Rate: Not determined Decomposition Temperature ( F):No data available
Flammability (solid, gas): No data available Viscosity, dynamic (cSt): No data available
Percent VOCs (%): 60 – 80
10. STABILITY AND REACTION
Chemical Stability: Stable.
Conditions to Avoid: Avoid contact with: Acetic acids Organic acid anhydrides. Powdered metals. Alkali. Alkaline earth metals. Ignition
sources such as open flames, sparks, static discharges or glowing metal surfaces. Strong oxidizing agents.
Decomposition Products: If heated with peroxides present, violent decomposition can occur. This material can be decomposed by extremely high
temperatures (open flames, glowing metal surfaces, etc.) forming hydrofluoric acid and carbonyl fluoride. Burning can
produce the following combustion products: Carbon dioxide and carbon monoxide. Various hydrocarbons.
11. TOXICOLOGICAL INFORMATION
Reproductive &
Developmental Toxicity:
No data available.
IARC Carcinogen Designation:No data available
Stoner Incorporated ME-301S/S553 PAGE 3
Ingredient CAS # Toxicological Data
No data available
12. ECOLOGICAL INFORMATION
Ecological Toxicity: No data available
Mobility: No data available
Ingredient CAS # Toxicological Data
Petroleum distillates 64741-65-7 Aquatic LC50 Bl gill > 1000 mg/L
24HR EC50 Daphnia > 1000 mg/L
24HR EC50 AQUATIC PLANTS > 1000 mg/L
13. DISPOSAL CONSIDERATIONS
Disposal : Dispose according to Federal, State and local regulations.
14. TRANSPORTATION INFORMATION
Agency UN Number Proper Shipping name Hazard Class Packing Group
DOT UN1950 Aerosols, Flammable 2.1 Not applicable
IATA ID8000 Consumer Commodity 9 Not applicable
IMDG UN1950 Aerosols, Flammable 2.1 Not applicable
“Limited Quantities” may be applicable for this transportation mode.
15. REGULATORY INFORMATION
Warning: This product contains the following chemicals that are subject to reporting requirements for the following regulatory bodies listed below:
COMPONENT CAS # % BY WEIGHT Regulatory Body
No components listed in this section. SARA Section 313
Toxic Substances Control Act
All components of this product are listed on the TSCA inventory.
California Prop 65
This product contains no California Proposition 65 ingredients that cause cancer, birth defects or other reproductive harm.
16. OTHER INFORMATION
Other Information : SDS Prepared by L. Dean Swartz, SDS Coordinator
Version Date: 07/02/18
This information contained in this SDS is believed to be accurate as of the version date, but is not warranted to be. Since the use of this
information and the conditions of use of this product are not within the control of Stoner Inc, it is the user’s obligation to determine the conditions
of safe use.