Page 1/8
Safety Data Sheet
acc. to OSHA HCS
Printing date 07/06/2020 Reviewed on 07/06/2020
51.0.8
1 Identification
Product identifier
Trade name: LAB 850
Article number:L850
Application of the substance / the mixtureUrethane Board
Details of the supplier of the safety data sheet
Sika Advanced Resins, US
EHS Department
Manufacturer/Supplier:
Supplier’s Name: Sika Advanced Resins, US
Headquarters:
30800 Stephenson Hwy
Madison Heights, MI 48071
USA
advancedresins.ehs@us.sika.com
Information department:Product safety department
Emergency telephone number:
During normal opening times: +1 (248) 588-2270
CHEMTREC 24-hour Emergency: +1 (800) 424-9300
2 Hazard(s) identification
Classification of the substance or mixture
Combustible Dust May form combustible dust concentrations in air.
Label elements
GHS label elementsThe substance is classified and labeled according to the Globally Harmonized System (GHS).
Hazard pictogramsVoid
Signal wordWarning
Hazard statements
May form combustible dust concentrations in air.
Classification system:
NFPA ratings (scale 0 – 4)
0
1
0
Health = 0
Fire = 1
Reactivity = 0
HMIS-ratings (scale 0 – 4)
HEALTH
FIRE
REACTIVITY
0
1
0
Health = 0
Fire = 1
Reactivity = 0
(Contd. on page 2)
US
Page 2/8
Safety Data Sheet
acc. to OSHA HCS
Printing date 07/06/2020 Reviewed on 07/06/2020
Trade name: LAB 850
(Contd. of page 1)
51.0.8
Other hazards
Results of PBT and vPvB assessment
PBT:Not applicable.
vPvB:Not applicable.
3 Composition/information on ingredients
Chemical characterization: Substances
CAS No. Description
Rigid Polymeric Block
4 First-aid measures
Description of first aid measures
After inhalation:Supply fresh air; consult doctor in case of complaints.
After skin contact:Generally the product does not irritate the skin.
After eye contact:Dust: Rinse opened eye for several minutes under running water, then consult a doctor.
After swallowing:If symptoms persist consult doctor.
Information for doctor:
Most important symptoms and effects, both acute and delayedNo further relevant information available.
Indication of any immediate medical attention and special treatment needed
No further relevant information available.
5 Fire-fighting measures
Extinguishing media
Suitable extinguishing agents:Use fire fighting measures that suit the environment.
Special hazards arising from the substance or mixture
Formation of toxic gases is possible during heating or in case of fire.
Advice for firefighters
Protective equipment:Wear self-contained respiratory protective device.
Additional information
Dispose of fire debris and contaminated fire fighting water in accordance with official regulations.
6 Accidental release measures
Personal precautions, protective equipment and emergency procedures
Avoid formation of dust.
Ensure adequate ventilation
Environmental precautions:Do not allow to enter sewers/ surface or ground water.
Methods and material for containment and cleaning up:Pick up mechanically.
Reference to other sections
See Section 7 for information on safe handling.
(Contd. on page 3)
US
Page 3/8
Safety Data Sheet
acc. to OSHA HCS
Printing date 07/06/2020 Reviewed on 07/06/2020
Trade name: LAB 850
(Contd. of page 2)
51.0.8
See Section 8 for information on personal protection equipment.
See Section 13 for disposal information.
Protective Action Criteria for Chemicals
PAC-1:
Substance is not listed.
PAC-2:
Substance is not listed.
PAC-3:
Substance is not listed.
7 Handling and storage
Handling:
Precautions for safe handling
Provide suction extractors if dust is formed.
Extractors are required on all machines used for thermal processing or splinter removal processes.
Any deposit of dust which cannot be avoided must be regularly removed.
Use appropriate industrial vacuum cleaners or central vacuum systems for dust removal.
Information about protection against explosions and fires:
Dust can combine with air to form an explosive mixture.
The product forms flammable fumes when heated.
Conditions for safe storage, including any incompatibilities
Storage:
Requirements to be met by storerooms and receptacles:No special requirements.
Information about storage in one common storage facility:Not required.
Further information about storage conditions:None.
Specific end use(s)No further relevant information available.
8 Exposure controls/personal protection
Additional information about design of technical systems:No further data; see item 7.
Control parameters
Components with limit values that require monitoring at the workplace:Not required.
Additional information:The lists that were valid during the creation were used as basis.
Exposure controls
Personal protective equipment:
General protective and hygienic measures:Wash hands before breaks and at the end of work.
Breathing equipment:Dust mask
Protection of hands:
Wear gloves for the protection against mechanical hazards according to EN 388.
(Contd. on page 4)
US
Page 4/8
Safety Data Sheet
acc. to OSHA HCS
Printing date 07/06/2020 Reviewed on 07/06/2020
Trade name: LAB 850
(Contd. of page 3)
51.0.8
The glove material has to be impermeable and resistant to the product/ the substance/ the preparation.
Due to missing tests no recommendation to the glove material can be given for the product/ the preparation/ the
chemical mixture.
Selection of the glove material on consideration of the penetration times, rates of diffusion and the degradation
Material of gloves
The selection of the suitable gloves does not only depend on the material, but also on further marks of quality and
varies from manufacturer to manufacturer.
Penetration time of glove material
The exact break through time has to be found out by the manufacturer of the protective gloves and has to be
observed.
Eye protection:Not required.
Body protection:Protective work clothing
9 Physical and chemical properties
Information on basic physical and chemical properties
General Information
Appearance:
Form: Solidified mass
Color: According to product specification
Odor: Odorless
Odor threshold: Not determined.
pH-value: Not applicable.
Change in condition
Melting point/Melting range:Undetermined.
Boiling point/Boiling range:Undetermined.
Flash point: Not applicable.
Flammability (solid, gaseous):Product is not flammable.
Decomposition temperature: Not determined.
Auto igniting: Not determined.
Danger of explosion: Product does not present an explosion hazard.
Explosion limits:
Lower: Not determined.
Upper: Not determined.
Vapor pressure: Not applicable.
Density at 20 C (68 F): 1.18 g/cm (9.85 lbs/gal)
Relative density Not determined.
Vapor density Not applicable.
Evaporation rate Not applicable.
(Contd. on page 5)
US
Page 5/8
Safety Data Sheet
acc. to OSHA HCS
Printing date 07/06/2020 Reviewed on 07/06/2020
Trade name: LAB 850
(Contd. of page 4)
51.0.8
Solubility in / Miscibility with
Water: Soluble.
Partition coefficient (n-octanol/water):Not determined.
Viscosity:
Dynamic: Not applicable.
Kinematic: Not applicable.
VOC content: 0.00 %
Solids content: 100.0 %
Other information No further relevant information available.
* 10 Stability and reactivity
ReactivityNo further relevant information available.
Chemical stability
Thermal decomposition / conditions to be avoided:No decomposition if used according to specifications.
Possibility of hazardous reactionsNo dangerous reactions known.
Conditions to avoidNo further relevant information available.
Incompatible materials:No further relevant information available.
Hazardous decomposition products:Carbon monoxide and carbon dioxide
11 Toxicological information
Information on toxicological effects
Acute toxicity:
Primary irritant effect:
on the skin:No irritant effect.
on the eye:No irritating effect.
Sensitization:No sensitizing effects known.
Additional toxicological information:
Carcinogenic categories
IARC (International Agency for Research on Cancer)
Substance is not listed.
NTP (National Toxicology Program)
Substance is not listed.
OSHA-Ca (Occupational Safety & Health Administration)
Substance is not listed.
US
(Contd. on page 6)
Page 6/8
Safety Data Sheet
acc. to OSHA HCS
Printing date 07/06/2020 Reviewed on 07/06/2020
Trade name: LAB 850
(Contd. of page 5)
51.0.8
12 Ecological information
Toxicity
Aquatic toxicity:No further relevant information available.
Persistence and degradabilityNo further relevant information available.
Behavior in environmental systems:
Bioaccumulative potentialNo further relevant information available.
Mobility in soilNo further relevant information available.
Additional ecological information:
General notes:
At present there are no ecotoxicological assessments.
Water hazard class 1 (Self-assessment): slightly hazardous for water
Do not allow undiluted product or large quantities of it to reach ground water, water course or sewage system.
Results of PBT and vPvB assessment
PBT:Not applicable.
vPvB:Not applicable.
Other adverse effectsNo further relevant information available.
13 Disposal considerations
Waste treatment methods
Recommendation:
The generation of the waste should be minimized whenever possble. Disposal of this product must comply with the
requirements of the the national and local regulations.
Must not be disposed of together with household garbage. Do not allow product to reach sewage system.
Uncleaned packagings:
Recommendation:Disposal must be made according to official regulations.
Recommended cleansing agent:Water, if necessary with cleansing agents.
14 Transport information
UN-Number
DOT, ADN, IMDG, IATA not regulated
UN proper shipping name Solid Plastic Mass, NOI
DOT, ADN, IMDG, IATA not regulated
Transport hazard class(es) Not regulated
DOT, ADN, IMDG, IATA
Class not regulated
Packing group Not regulated
DOT, IMDG, IATA not regulated
(Contd. on page 7)
US
Page 7/8
Safety Data Sheet
acc. to OSHA HCS
Printing date 07/06/2020 Reviewed on 07/06/2020
Trade name: LAB 850
(Contd. of page 6)
51.0.8
Environmental hazards:
Marine pollutant: No
Special precautions for user Not applicable.
Transport in bulk according to Annex II of
MARPOL73/78 and the IBC Code Not applicable.
UN “Model Regulation”: not regulated
15 Regulatory information
Safety, health and environmental regulations/legislation specific for the substance or mixture
Sara
Section 355 (extremely hazardous substances):
Substance is not listed.
Section 313 (Specific toxic chemical listings):
Substance is not listed.
TSCA (Toxic Substances Control Act):
ACTIVE
Chemicals regulated by TSCA Section 12(b)
Substance is not listed.
Chemical regulated by TSCA 5(a)(2)rule:
Substance is not listed.
Hazardous Air Pollutants
Substance is not listed.
Proposition 65
Chemicals known to cause cancer:
Substance is not listed.
Chemicals known to cause reproductive toxicity for females:
Substance is not listed.
Chemicals known to cause reproductive toxicity for males:
Substance is not listed.
Chemicals known to cause developmental toxicity:
Substance is not listed.
Carcinogenic categories
EPA (Environmental Protection Agency)
Substance is not listed.
(Contd. on page 8)
US
Page 8/8
Safety Data Sheet
acc. to OSHA HCS
Printing date 07/06/2020 Reviewed on 07/06/2020
Trade name: LAB 850
(Contd. of page 7)
51.0.8
TLV (Threshold Limit Value established by ACGIH)
Substance is not listed.
NIOSH-Ca (National Institute for Occupational Safety and Health)
Substance is not listed.
Listed in CWC Regulations
Substance is not listed.
GHS label elementsThe substance is classified and labeled according to the Globally Harmonized System (GHS).
Hazard pictogramsVoid
Signal wordWarning
Hazard statements
May form combustible dust concentrations in air.
Chemical safety assessment:A Chemical Safety Assessment has not been carried out.
16 Other information
This information is based on our present knowledge. However, this shall not constitute a guarantee for any
specific product features and shall not establish a legally valid contractual relationship.
Date of preparation / last revision07/06/2020 / 16
Abbreviations and acronyms:
IMDG: International Maritime Code for Dangerous Goods
DOT: US Department of Transportation
IATA: International Air Transport Association
ACGIH: American Conference of Governmental Industrial Hygienists
CAS: Chemical Abstracts Service (division of the American Chemical Society)
NFPA: National Fire Protection Association (USA)
HMIS: Hazardous Materials Identification System (USA)
VOC: Volatile Organic Compounds (USA, EU)
PBT: Persistent, Bioaccumulative and Toxic
vPvB: very Persistent and very Bioaccumulative
NIOSH: National Institute for Occupational Safety
OSHA: Occupational Safety & Health
TLV: Threshold Limit Value
PEL: Permissible Exposure Limit
REL: Recommended Exposure Limit
* Data compared to the previous version altered.
US