ACS International Products, L.P. – SDS
Featherlite Series
Page:1of3
Last Revised: 4/9/2019
Print Date: 4/9/2019
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Trade name:
General Use:
Featherlite 20, 50, 1000, 1500, 1700, 1250-LD
Filler material
Manufacturer Name
ACS International Products, L.P.
4775 S. Third Avenue
Tucson, AZ 85714
Tel: 520.889.1933
Emerqency Information
Emergency Telephone: 1-800-669-9214
Direct: 1-520-889-1933 M-Th: 7am to 4 pm, F: 7 to 11 am
2. HAZARDS IDENTIFICATION
Most lmportant Hazards: This product may irritate eyes and skin upon prolonged or repeated exposure. Inhalation of high
concentrations of dust may produce irritation of the respiratory tract. Not considered tobe toxic.
Specific Hazards: There is no known effect from chronic exposure to this product.
Potential health effects
Primary routes of exposure: Eye Contact-Yes lnhalation-Yes Skin-Yes Ingestion-No Skin Absorption-No
Symptoms of acute overexposure:
Skin: Extensive skin contact may cause dry irritated skin.
Eyes: lrritant by mechanical means.
Inhalation: Inhalation of dust may produce respiratory tract irritation, characterized by burning, sneezing and
coughing.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Chemical Name
Abbr.
CAS No.
EIN
No.
Weight%
ECC No.
(lass
ACGIH TLV
OSHA
PEL
Other
Limits
Calcium
carbonate
1317-65-3
95-98%
N/A
N/A
15mg/M
5 (Total)
lsopentane
(encapsulated
in polymer)
78-78-4
<1% 601-006-00-1 3 N/A N/A N/A Crystaline Silica 14808-60-7 < .01% .10 mg/M3 .10mg/ M3(Resp) 4. FIRST AID MEASURES Skin: Eyes: Inhalation: Ingestion: May cause skin irritation. Wash contaminated skin with soap and water. Use a moisturizing lotion on dry irritated skin. Seek medical attention if irritation persists. May cause eye irritation. lf contact lenses are present, remove. lmmediately flush eyes with running water for a minimum of 15 minutes. Seek medical attention if irritation persists. Inhalation of dust may produce respiratory tract irritation, characterized by burning, sneezing and coughing. Remove individual to fresh air and allow to rest. Obtain medical assistant is breathing remains labored. Not applicable under normal industrial situations. Give large quantities of water to induce vomiting. Seek medical attention. 5. FIRE FIGHTING MEASURES ACS International Products, L.P. - SDS Featherlite Series Page:2of3 Last Revised: 4/9/2019 Print Date: 4/9/2019 Extinguishing Media: Water-Yes Carbon Dioxide-Yes Dry Chemical-Yes Foam-Yes Alcohol Foam-No Use a self-contained breathing apparatus approved by NIOSH for all fires. Flash Point: Non-combustible. No reported flammable limits. Explosive limits in air: N/A Unusual Fire and Explosion Hazard: Generally non-flammable; calcium carbonate will ignite on contact with fluorine. NFPA Classification: Flammable: 0 Health: 0 Reactivity: 0 Specific Hazards: 0 Special Remarks: In a sustained fire, calcium carbonate can produce calcium oxide. 6. ACCIDENTAL RELEASE MEASURES This product does not meet the criteria of a hazardous waste as defined under 40 CFR 261, RCRA. Spill Control: For small spills vacuum or scoop-up material for recovery or disposal in a sanitary landfill. Avoid dust producing conditions and use good ventilation. Water may be applied to spill to decrease dust. 7. HENDLING AND STORAGE Handling precautions: Avoid contact with skin and eyes. Do not breathe dust in concentrations above established limits. Afterhandling, always wash hands thoroughly with soap and water before eating, drinking, or smoking. Use process enclosures, local exhaust ventilation, or other engineering controls to keep airborne levels low. Storage: Store in a dry, cool and weil ventilated area. Avoid damaging storage containers. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Engineering Controls: Store/use in a weil ventilated area. Personal Protection Equipment Respiratory: Wear a filtering face piece dust mask wear ventilation is not adequate. Eye: Safety glasses with side shields are recommended. Skin: Where skin exposure is likely to occur, long sleeved clothing is recommended. Exposure Limits: Calciumsulfate: 15 mg/m3, 5 mg/m3 respirable fraction, for particulates not otherwise regulated. lsopentante: N/A 9. PHYSICAL AND CHEMICAL PROPERTIES Form: Granular solid. Color: White Odor: Little Specific Gravity: Solubility: 1.5-1.6 Insoluble in water Boiling Point: N/A Melting Point: N/A 10. STABILITY AND REACTIVITY Stability: lncompatibility: Decomposition: This product is stable. Avoid acids and other oxidizers. Avoid damage to containers. In a sustained fire, calcium sulfate can produce calcium oxide. 11. TOXICOLOGICAL INFORMAITON Significant Routes of Exposure: Inhalation. 12. ECOLOGICAL INFORMATION Ecotoxicity: Low toxicity for humans or animals under normal conditions of use. This product is slightly water soluble (calcium sulfate only). ACS International Products, L.P. Featherlite Series ACS International Products, L.P. - SDS Page:3of3 Last Revised: 4/9/2019 Print Date: 4/9/2019